| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 35 |
| Brakes imbalanced across an axle | 29 |
| Registration plate lamp issues | 22 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Rear parking brake recording little or no effort | 16 |
| Headlamp aim out of alignment | 16 |
| Rear brake binding | 14 |
| Horn not working |1.6.2a| | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Offside front brake binding |3.7.B.1| | 7 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Nearside front brake binding |3.7.B.1| | 6 |
| Front brake application uneven | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Rear brake application uneven | 5 |
| Brake hose has insufficient room to move | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 4 |
| Registration plate issues | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Battery insecure |1.9.1| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 2 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear front brake binding |3.7.B.1| | 2 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel pipe leaked on a union joint (1.2.1 (a) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Parking brake efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Centre Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Mechanical brake component securing device missing |3.5.1i| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Front Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
| Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Inner Front Lower Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Outer Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Brake pipe excessively corroded | 1 |
| Outer Fuel pipe leaking |7.2.3| | 1 |
| Offside Outer Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Outer Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Lower Steering column flexible coupling insecure Spline |2.1.5| | 1 |
| Offside Front Steering system fouling |2.2.D.2a| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Horn control missing |1.6.1| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Lower Suspension arm worn and seriously weakened |2.4.G.1| | 1 |
| Rear Lower Spare wheel carrier insecure |6.4.2| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Brake hose damaged | 1 |
| Nearside Rear Suspension arm pin or bush likely to become detached traction arm front bush loose (5.3.4 (a) (ii)) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension component pin or bush excessively worn trunnion (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Road wheel distorted |4.2.A.1a| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |