| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 22 |
| Headlamp aim out of alignment | 20 |
| Rear brake binding | 19 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Brake hose excessively deteriorated | 17 |
| Rear parking brake recording little or no effort | 12 |
| Brakes imbalanced across an axle | 10 |
| Horn not working |1.6.2a| | 8 |
| Registration plate lamp issues | 8 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Nearside Headlamp not working on main beam |1.7.5a| | 7 |
| Brake pipe excessively corroded | 7 |
| Offside Headlamp not working on main beam |1.7.5a| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 6 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 5 |
| Offside Steering rack gaiter split |2.2.D.2d| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Rear brake application uneven | 4 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| All position lamps not working |1.1.A.3b| | 3 |
| Registration plate issues | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen washer not working | 3 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
| Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Fuel pipe insecure |7.2.1| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake pedal actuating linkage has excessive wear in the eye of the stationary pivot |3.3.A.1g| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake servo leaking |3.6.C.1c| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Direction indicators not working All Lights Flashing Into Each Other |1.4.A.2c| | 1 |
| Rear Rear position lamp|s| not working Flashing Into Indicators |1.1.A.3b| | 1 |
| Front brake application uneven | 1 |
| Direction indicators not working indicators not flashing |1.4.A.2c| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Coil spring mounting insecure top mount cup bent in |5.3.1 |a| |i|| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Offside Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Inner Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Obligatory mirror missing |8.1.1| | 1 |
| Nearside Inner Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Windscreen wiper not operating automatically when switched on all |8.2.1b| | 1 |
| Nearside Outer Rear Upper Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| An item not tested |Manual| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded Chassis |2.4.A.3| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Direction indicator not working front and rear (4.4.1 (a) (ii)) | 1 |
| Offside Rear Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Steering rack gaiter split both |2.2.D.2d| | 1 |
| Fuel tank leaking pipe to tank |7.2.3| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect dip beam |1.8.A.1b| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Steering rack insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Fluid leaking continuously posing a serious risk to road safety slave cylinder (8.4.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Integral body structure inadequately repaired such that structural rigidity is significantly reduced nearside sill to inner sill/floor (6.1.1 (d) (i)) | 1 |
| Integral body structure inadequately repaired such that structural rigidity is significantly reduced offside sill to inner sill/floor (6.1.1 (d) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Rear Service brake effort inadequate at a wheel AXLE |1.2.1 |a| |i|| | 1 |
| Nearside Rear Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength door shut |5.3.6 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust system not adequately supported back box |7.1.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength trailing arm mount / tie bar (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Stop lamp adversely affected by the operation of another lamp position lights |1.2.1f| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Fuel pipe leaking |7.2.3| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Outer Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded under arch |2.4.A.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Coil spring not correctly located |2.4.C.2| | 1 |
| Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded sill floor area body mounting area |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |