Most common failures | No# failures |
---|
Horn not working |1.6.2a| | 13 |
Headlamp aim out of alignment | 12 |
Registration plate lamp issues | 11 |
Brakes imbalanced across an axle | 11 |
Parking brake: efficiency below requirements |3.7.B.7| | 10 |
Rear brake binding | 9 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Rear parking brake recording little or no effort | 7 |
Offside front brake binding |3.7.B.1| | 6 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Brake pipe excessively corroded | 6 |
Offside Stop lamp not working |1.2.1b| | 5 |
Windscreen wiper does not clear the windscreen effectively | 5 |
Rear Mechanical brake component has restricted free movement | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Offside Steering rack gaiter split |2.2.D.2d| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
Battery insecure |1.9.1| | 3 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Registration plate issues | 2 |
Fuel pipe leaking |7.2.3| | 2 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Brake hose excessively deteriorated | 2 |
Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Exhaust has a part missing |7.1.1a| | 2 |
Nearside Inner Front drive shaft coupling flexible rubber or fabric coupling unit severely cracked |2.5.C.1d| | 1 |
Nearside Front Inner Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Front Service brake excessively binding |1.2.1 |f|| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Inner Front Front drive shaft coupling flexible rubber or fabric coupling unit severely cracked |2.5.C.1d| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Steering component damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Brake pedal excessively corroded |3.3.A.1a| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Inner Subframe mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
Offside Rear Inner Subframe mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Mechanical brake component has restricted free movement | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension locking device missing hub nut split pin |2.5.A.4| | 1 |
Nearside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Offside Front Front drive shaft coupling flexible rubber or fabric coupling softened by oil contamination |2.5.C.1e| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Road wheel more than one fixing loose both fron & o/s rear (5.2.1 (a) (ii)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Nearside Front Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 1 |
Offside Front Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 1 |
Offside Lower Steering column attachment defective (2.2.2 (d) (i)) | 1 |
Offside Front Upper Suspension arm ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
Nearside Rear Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Central Rear Subframe mounting prescribed area is excessively corroded as marked |2.4.A.3| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded as marked |2.4.A.3| | 1 |
Nearside Front Subframe mounting prescribed area is severely distorted as marked |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded as marked |2.4.A.3| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded lower arm mount broken away |2.4.A.3| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Offside Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Brake pedal has excessive side movement indicating a badly worn bearing or pivot |3.3.A.1d| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering chassis leg |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering chassis leg |2 places| |6.1.A.1| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor pan |6.1.B.2| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear wheel cylinder securing device loose |3.5.1j| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Front Fuel pipe leaking |7.2.3| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Lower Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 1 |
Nearside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm attachment bracket/mounting fractured |2.4.G.1| | 1 |
Centre Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Centre Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Parking brake lever, pawl mechanism pivot|s| retaining device missing |3.1.4b| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Outer Rear Exhaust system not adequately supported |7.1.1| | 1 |