| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Brake pipe excessively corroded | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Brakes imbalanced across an axle | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Registration plate lamp issues | 3 |
| Registration plate issues | 2 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Seat belt missing (7.1.2 (a)) | 2 |
| Offside Rear Seat belt missing (7.1.2 (a)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Side repeater missing |1.4.A.2b| | 2 |
| Offside Side repeater missing |1.4.A.2b| | 2 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 2 |
| Offside Rear Statutory seat belt missing |5.1.1| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Front Integral body structure is fractured and structural rigidity is significantly reduced subframe mount (6.1.1 (a) (i)) | 1 |
| Offside Rear Integral body structure is fractured and structural rigidity is significantly reduced subframe mounting (6.1.1 (a) (i)) | 1 |
| Offside Integral body structure is fractured and structural rigidity is significantly reduced inner sill middle and front (6.1.1 (a) (i)) | 1 |
| Offside Front Integral body structure is fractured and structural rigidity is significantly reduced subframe mounting (6.1.1 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner arch (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Boot floor (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Boot floor (6.2.2 (d) (i)) | 1 |
| Brake performance not tested Due to coolant loss (1.2.1 (g)) | 1 |
| Emissions not tested Due to coolant loss (8.2.1.2 (d)) | 1 |
| Nearside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is inadequately repaired (inner wheel arch) (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (inner arch) (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill front to rear (7.1.1 (a) (i)) | 1 |
| Central Rear Towbar component excessively corroded rear crash bar corroded next to tow bar (6.1.6 (a)) | 1 |
| Nearside Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting boot floor (6.2.2 (d) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Centre Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Seat belt anchorage prescribed area is severely distorted |5.2.6| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Centre Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear brake application uneven | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded floor holed |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor holed |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is severely distorted inner sill |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Front Electrical wiring insecure |1.9.2a| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |