| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 29 |
| Registration plate lamp issues | 25 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 20 |
| Brake hose excessively deteriorated | 19 |
| Headlamp aim out of alignment | 16 |
| Offside Rear fog lamp not working |1.3.2b| | 13 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Rear fog lamp not working |1.3.2b| | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 9 |
| Brakes imbalanced across an axle | 9 |
| Registration plate issues | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear fog lamp switch missing |1.3.1a| | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| Windscreen has damage | 3 |
| Emissions not tested |7.0| | 3 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Emissions not tested |7.4.B.1| | 2 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Rear brake binding | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Front brake application uneven | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Rear fog lamp insecure |1.3.2a| | 2 |
| Brake pipe excessively corroded | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Brake hose damaged | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear brake application uneven | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front front brake binding wheel will not turn,due to suspect brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Central Rear Exhaust has a major leak of exhaust gases box spilt blowing |7.1.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Inner Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Inner Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Offside Front Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush bush |2.4.G.2| | 1 |
| Speedometer clearly inoperative |6.7.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` various air freshners |8.3.1b| | 1 |
| Emissions not tested excessive black smoke |7.4.B.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Stop lamp not working |1.2.1b| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| An item not tested |Manual| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.2| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Front suspension locking device ineffective |2.5.A.4| | 1 |
| Nearside Front suspension locking device ineffective |2.5.A.4| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Central Front Exhaust has a major leak of exhaust gases front to rear exhaust holed |6.1.2 |a|| | 1 |
| Nearside Front Brake hose excessively damaged chaffing caliper and chassis |1.1.12 |b| |ii|| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Headlamp extinguishes when tapped lightly by hand |1.2.4c| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Centre Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Emissions not tested (7.0) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Parking brake: efficiency below requirements (3.7.C.1b) | 1 |
| Offside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced far rear inner sill/arch (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced o/s inner sill corroded + holed (6.1.1 (c) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Central Rear Seat belt missing (7.1.2 (a)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Central Rear Seat belt buckle not functioning as intended middle row (7.1.2 (d)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Brake lining(s) contaminated (1.1.13 (b)) | 1 |