| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Headlamp aim out of alignment | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Fuel cap/sealing device missing |6.1.3 |b| |i|| | 1 |
| Nearside Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Offside Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Anti-roll bar insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D BUSH |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D BUSH |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement D BUSH |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement D BUSH |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure D BUSH BRACKET |2.4.G.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Registration plate lamp issues | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Fuel system component leaking tank area |7.2.3| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Windscreen washer not working | 1 |
| Body has a sharp edge caused by corrosion front crash bar |6.1.C.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Fuel system component leaking large fuel leak from fuel tank area |7.2.3| | 1 |