| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Headlamp aim out of alignment | 16 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 15 |
| Registration plate issues | 10 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Windscreen washer not working | 4 |
| Brakes imbalanced across an axle | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 3 |
| Brake hose has insufficient room to move | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Registration plate lamp issues | 3 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Brake hose damaged | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 2 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 2 |
| Rear fog lamp switch missing (4.5.3 (a)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Anti-lock braking system warning lamp is missing. |3.4.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Brake hose leaking on a hydraulic braking system to caliper (1.1.12 (c) (ii)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases centre joint (6.1.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced SILL/FLOOR CORRODED (7.1.1 (a) (i)) | 1 |
| Rear Anti-roll bar fractured (5.3.3 (b) (ii)) | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill corroded & Holed ( Previous Repair ) (5.3.6 (a) (i)) | 1 |
| Rear Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Nearside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill/arch closure panel (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Central Front Lower Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired Front Crossmember Holed & Corroded (6.2.2 (d) (ii)) | 1 |
| Nearside Rear Fuel pipe leaking Under Vehicle (6.1.3 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Headlamp light intensity severely reduced both (4.1.4 (a)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Rear Anti-roll bar cracked |2.4.G.1| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Emissions not tested Due to over heating (8.2.1.2 (d)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Both sides (4.1.2 (c)) | 1 |
| Rear Anti-roll bar missing |2.4.G.1| | 1 |
| Nearside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen no beam pattern both sides |4.1.2 |a|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear brake application uneven | 1 |
| Rear brake binding | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Body panel corroded and likely to cause injury both sides seal. (6.2.1 (a) (i)) | 1 |
| Rear Body panel corroded and likely to cause injury both sides seal. (6.2.1 (a) (i)) | 1 |
| Central Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Brake pipe likely to become detached or damaged insecure. (1.1.11 (d) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Front Headlamp light source and lamp not compatible both side. (4.1.4 (c)) | 1 |
| Nearside Front Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Rear Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Front Horn not working |1.6.2a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Drivers seat insecure securing bolts are loose (6.2.5 (a) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Front Brake disc contaminated (1.1.14 (b)) | 1 |
| Offside Front Brake disc contaminated (1.1.14 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Tie bar/rod synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |