| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate lamp issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Brakes imbalanced across an axle | 7 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 6 |
| Offside front brake binding |3.7.B.1| | 5 |
| Rear fog lamp emits a light other than red |1.3.2e| | 5 |
| Brake hose excessively deteriorated | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Registration plate issues | 4 |
| Brake hose has insufficient room to move | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Windscreen has damage | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Rear fog lamp switch missing (4.5.3 (a)) | 2 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 2 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Fuel system component leaking Fuel filter (6.1.3 (b) (i)) | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Inner Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front brake application uneven | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect outer lens cracked (4.1.2 (c)) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Exhaust has a major leak of exhaust gases front pipe to centre pipe joint |6.1.2 |a|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust has a major leak of exhaust gases cat area |6.1.2 |a|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Parking brake inoperative on one side very low effort |1.4.1 |a|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Offside Front Position lamp not working side light (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Inner Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases pipe holed (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases pipe holed (6.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced both front |1.7.5a| | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch (6.1.1 (c) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Emissions not tested due to black smoke |8.2.1.2 |d|| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear brake binding | 1 |
| Offside Front Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush wishbone |2.4.G.2| | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Inner Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Side repeater incomplete |1.5.A1b| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Outer Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Braking system leaking (1.1.3 (d)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system caliper bleed nut (1.1.11 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected |5.3.6 |a| |ii|| | 1 |
| Offside Front Suspension arm attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |