| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Registration plate lamp issues | 12 |
| Brake hose excessively deteriorated | 10 |
| Headlamp aim out of alignment | 10 |
| Registration plate issues | 10 |
| Rear fog lamp tell tale not working |1.3.1b| | 8 |
| Brakes imbalanced across an axle | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Rear fog lamp switch missing |1.3.1a| | 7 |
| Offside Rear fog lamp missing |1.3.2a| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Offside front brake binding |3.7.B.1| | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Rear brake binding | 5 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 5 |
| Brake pipe excessively corroded | 5 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 4 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Front brake application uneven | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Brake performance not tested |3.7.A.1| | 3 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 3 |
| Mechanical brake component has restricted free movement | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Rear brake application uneven | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 2 |
| Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Central Front Exhaust catalytic converter missing where one was fitted as standard |8.2.1.1 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Brake hose excessively stretched |1.1.12 |b| |ii|| | 1 |
| Offside Front Brake hose excessively stretched |1.1.12 |b| |ii|| | 1 |
| Nearside Front Upper Suspension component attachment bracket/mounting damaged and seriously weakened stub axle bent |5.3.3 |b| |i|| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Emissions not tested Vissible smoke and CO reading both excessive (8.2.1.2 (d)) | 1 |
| Brake hose damaged | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Exhaust emits excessive dense blue smoke during acceleration (8.2.1.2 (g)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn marked yellow (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe marked yellow (5.3.6 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced prescribed area with 30cm of selt belt anchorage and seat anchorage (7.1.1 (a) (i)) | 1 |
| Rear Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Nearside Rear Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Headlamp aim beam image obviously incorrect both front |1.8.A.1b| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Front Brake performance not tested |3.7.A.1| | 1 |
| Rear Brake performance not tested |3.7.A.1| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Outer Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Upper Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |