| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 31 |
| Headlamp aim out of alignment | 23 |
| Registration plate lamp issues | 14 |
| Brake pipe excessively corroded | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Rear brake disc in such a condition that it is seriously weakened | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Registration plate issues | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Front brake excessively fluctuating | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Brakes imbalanced across an axle | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Rear brake binding | 2 |
| Windscreen wiper blade insecure | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Horn sound not in accordance with requirements harsh (7.7 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt detached (2.1.3 (g) (ii)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Brake disc fractured (1.1.14 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt both front |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Offside Front Body component damaged and likely to cause injury wing mirror unit (6.2.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases rear back box section (6.1.2 (a)) | 1 |
| Headlamp levelling device inoperative broken at rear axle (4.1.5 (a)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |Back Box| |7.1.2| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both side (4.1.2 (c)) | 1 |
| Rear Brake disc significantly and obviously worn both side brake discs corroded (1.1.14 (a) (i)) | 1 |
| Rear Exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Offside Front Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Rear Wheel bearing so rough it is likely to overheat or break up (5.1.3 (b) (ii)) | 1 |
| Rear Parking brake efficiency less than 50% of the required value both (1.4.2 (a) (ii)) | 1 |
| Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface tail lamp (4.8.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases backbox |7.1.2| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam bulb connector faulty (now working) (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working tapped and started working (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases back box. (6.1.2 (a)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt Both sides (5.3.4 (b) (ii)) | 1 |
| Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Front Position lamp not working sidelight (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp lens seriously defective opaque (4.1.1 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Rear back box. |6.1.2 |a|| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Lower Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced Both sides (4.1.4 (b)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases back box |7.1.2| | 1 |
| Front brake application uneven | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Hydraulic brake cylinder damaged and braking performance affected REAR BRAKE COMPENSATOR SNAPPED (1.1.16 (a) (ii)) | 1 |
| Offside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt SPLIT (6.1.7 (g) (ii)) | 1 |
| Nearside Ball joint has excessive play in steering rack (2.2.B.1f) | 1 |
| Offside Ball joint has excessive play in steering rack (2.2.B.1f) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Suspension arm pin or bush excessively worn front both side (5.3.4 (a) (i)) | 1 |
| Nearside Front All position lamps light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Electronic braking system warning device indicates a fault (1.7 (b)) | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sil (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |