| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 52 |
| Headlamp aim out of alignment | 38 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 9 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Registration plate lamp issues | 9 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 7 |
| Brake pipe excessively corroded | 7 |
| Registration plate issues | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Offside Rear coil spring broken |2.4.C.1a| | 5 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 3 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 3 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 3 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 3 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front Anti-roll bar likely to become detached (5.3.3 (a) (ii)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
| Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Service brake has no recorded effort at a wheel o/s n/s |1.2.1 |a| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired |5.1.3 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp reflector seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Front Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced no aim pattern due to product on lens |4.1.4 |b|| | 1 |
| Nearside Front Headlamp light intensity severely reduced need to be cleaned (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced need to be cleaned (4.1.4 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust system not adequately supported silencer adrift from exhaust due to corrosion |7.1.1| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Emissions oxygen sensor missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Windscreen washer not working | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt both |5.3.4 |b| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Split (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Upper Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Rear Stop lamp not working (1.2.1b) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm bush |5.3.4 |a| |i|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Suspension component pin or bush excessively worn both rear trailing arm bushes |5.3.4 |a| |i|| | 1 |
| Rear Suspension component pin or bush excessively worn axle bushes worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension component pin or bush excessively worn Trailing arm bush, as marked |5.3.4 |a| |i|| | 1 |
| Offside Rear Suspension component pin or bush excessively worn Trailing arm bush, as marked |5.3.4 |a| |i|| | 1 |
| Offside Inner Steering linkage ball joint has excessive play Tie rod |2.1.3 |b| |i|| | 1 |
| Offside Rear Road wheel fixing missing nut (5.2.1 (a) (i)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| not working dip bream |1.1.A.3b| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |