| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 46 |
| Headlamp aim out of alignment | 33 |
| Registration plate lamp issues | 26 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 15 |
| Registration plate issues | 10 |
| Offside Rear coil spring broken |2.4.C.1a| | 9 |
| Brake pipe excessively corroded | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 7 |
| Rear brake binding | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Rear coil spring broken |2.4.C.1a| | 6 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 5 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 5 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Rear parking brake recording little or no effort | 5 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Offside Rear coil spring fractured |2.4.C.1a| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Front brake application uneven | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 3 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 3 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 3 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear Service brake indicates brake bind |3.7.D.2a| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear coil spring cracked |2.4.C.1a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Body has a projection caused by damage |6.1.C.1| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired |5.1.3 |a| |ii|| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Front Position lamp not working Both (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt N/S/F & O/S/F (6.1.7 (g) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp has a product on the lens which changes emitted colour to other than white or yellow (4.1.4 (b)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 1 |
| Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Rear Stop lamp obscured more than 50% |1.2.1c| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement Wishbone arm |rear| bush |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Suspension arm pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill inner and outer (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner and outer sills (6.1.1 (d) (i)) | 1 |
| Nearside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner and outer sills (6.1.1 (d) (i)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Front Headlamp aim beam image obviously incorrect BOTH |1.8.A.1b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Rear Body panel damaged and likely to cause injury Wheel arch |6.2.1 |a| |i|| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured outer sill damaged |2.4.A.3| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Front Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp light source and lamp not compatible LED fitted (4.1.4 (c)) | 1 |
| Offside Headlamp light source and lamp not compatible LED fitted (4.1.4 (c)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Exhaust has a part missing |7.1.1a| | 1 |
| Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Front Headlamp has more than 1/2 LEDs not functioning (4.1.1 (a) (ii)) | 1 |
| Central Front Exhaust has a major leak of exhaust gases joint (6.1.2 (a)) | 1 |
| Rear Exhaust shield missing where fitted as original equipment creating a risk of fire box (6.1.3 (e)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Shock absorber has an excessively worn linkage |2.7.4| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch/sills both sides (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Windscreen has damage | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper coil spring cracked |2.4.C.1a| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Central Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Central Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Rear brake application uneven | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |