| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 34 |
| Headlamp aim out of alignment | 19 |
| Registration plate lamp issues | 13 |
| Rear brake binding | 8 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Registration plate issues | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Brake pipe excessively corroded | 2 |
| Central Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt BOTH SIDES |5.3.4 |b| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn front arm bush (5.3.4 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer and closing sills excessively corroded (7.1.1 (a) (i)) | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced Both sides (4.1.4 (b)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Outer lens deteriorated. |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect Outer lens deteriorated. |4.1.2 |c|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect lens glazed (4.1.2 (c)) | 1 |
| Nearside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced Excessively deteriorated (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced Excessively deteriorated (4.1.4 (b)) | 1 |
| Central Rear Seat belt missing Buckle (7.1.2 (a)) | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Front Headlamp lens seriously defective n/s,o/s |4.1.1 |b| |ii|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.2.1 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced both (4.1.4 (b)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Upper Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Front Shock absorber has a serious fluid leak (2.7.3) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Exhaust system not adequately supported rear exhaust clamp broken |7.1.1| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front brake application uneven | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |