Most common failures | No# failures |
---|
Registration plate lamp issues | 66 |
Parking brake: efficiency below requirements |3.7.B.7| | 53 |
Headlamp aim out of alignment | 45 |
Rear parking brake recording little or no effort | 37 |
Windscreen wiper does not clear the windscreen effectively | 33 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 13 |
Brake pipe excessively corroded | 13 |
Parking brake lever has no reserve travel |3.1.6b| | 12 |
Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
Offside Stop lamp not working |1.2.1b| | 12 |
Nearside Stop lamp not working |1.2.1b| | 10 |
Brake hose excessively deteriorated | 10 |
Centre Stop lamp not working |1.2.1b| | 9 |
Registration plate issues | 9 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
Brakes imbalanced across an axle | 7 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Battery insecure |1.9.1| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Nearside Rear Stop lamp not working |1.2.1b| | 5 |
Offside Rear Stop lamp not working |1.2.1b| | 5 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Rear brake binding | 4 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 4 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Anti-lock braking system warning lamp indicates an ABS fault | 3 |
Windscreen has damage | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
Rear brake application uneven | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Windscreen wiper blade insecure | 2 |
Nearside Front All position lamps not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
Emissions not tested |7.0| | 2 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Centre Rear Stop lamp not working |1.2.1b| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Front brake application uneven | 2 |
Parking brake: efficiency below requirements |3.7.D.4| | 2 |
Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside Front All position lamps have less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Front All position lamps not working |1.1.A.3b| | 1 |
Offside Rear Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Rear Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded front to rear inner sill |2.4.A.3| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded rear inner sill |2.4.A.3| | 1 |
Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Suspension arm pin or bush excessively worn rear bush split (5.3.4 (a) (i)) | 1 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Rear Brake pipe kinked |3.6.B.2b| | 1 |
Centre Rear Brake pipe kinked |3.6.B.2b| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front position lamp|s| missing |1.1.A.3a| | 1 |
Nearside Front Direction indicator missing |1.4.A.2b| | 1 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Rear obligatory indirect vision device missing |8.1.1| | 1 |
Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Nearside Rear Front position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Brake hose leaking |3.6.A.1| | 1 |
Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Statutory seat belt missing |5.1.1| | 1 |
Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
Centre Rear Statutory seat belt missing |5.1.1| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
Brake lever has insufficient reserve travel hand brake no res travel |1.1.2 |a|| | 1 |
Power steering inoperative and steering adversely affected |2.1.5 |c| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Rear Exhaust silencer likely to become detached exhaust bracket rubbing onto towbar (8.1.1 (b) (ii)) | 1 |
Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Power steering fluid level below minimum |2.3.1| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Service brake grabbing severely n/s front |3.7.C.2| | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Centre Rear Seat belt flexible stalk cable has broken strands |5.2.4b| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Nearside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Offside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Nearside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
Offside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Parking brake lever is impeded in its travel |3.1.6c| | 1 |
Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Spare wheel carrier insecure |6.4.2| | 1 |
Spare wheel insecure |6.4.2| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Front Front position lamp|s| not working n/s and o/s |1.1.A.3b| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Inner Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement rear wishbone bush split |2.4.G.2| | 1 |
Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Front Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Centre Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
Offside Front Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front Steering wheel in a condition likely to injure the driver`s hands |2.1.1| | 1 |
Offside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
Offside Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Front Front suspension locking device missing |2.5.A.4| | 1 |
Front brake caliper securing device excessively deteriorated |3.5.1j| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Exhaust silencer insecure silencer |8.1.1 |b| |i|| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
Nearside Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn dust cover split |5.3.4 |a| |i|| | 1 |
Nearside Rear Parking brake inoperative on one side nearside parking brake poor efficiency |1.4.1 |a|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Hand operated control valve control cannot be moved over its full travel |3.2.1c| | 1 |
Nearside Inner Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Brake hose damaged | 1 |
Nearside Steering rack insecure mounting bushes worn |2.2.B.1a| | 1 |
Offside Steering rack insecure mounting bushes worn |2.2.B.1a| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Centre Upper Stop lamp not working |1.2.1b| | 1 |