| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 26 |
| Headlamp aim out of alignment | 23 |
| Brake hose excessively deteriorated | 13 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Brake pipe excessively corroded | 5 |
| Brakes imbalanced across an axle | 5 |
| Registration plate issues | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Windscreen has damage | 4 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Battery insecure |1.9.1| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Centre Rear Statutory seat belt missing |5.1.1| | 2 |
| Centre Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Front brake application uneven | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake hose damaged | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Centre Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Offside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Jacking Point (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Jacking Point (6.2.2 (d) (i)) | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Rear Inner Subframe mounting prescribed area is excessively corroded SILL |2.4.A.3| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Outer Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Offside Rear position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Valve stem seriously misaligned |4.1.D.1e| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Emissions not tested |7.0| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Front front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |