| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 120 |
| Registration plate lamp issues | 109 |
| Headlamp aim out of alignment | 101 |
| Brake pipe excessively corroded | 78 |
| Registration plate issues | 43 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 25 |
| Nearside Stop lamp not working |1.2.1b| | 17 |
| Parking brake lever has no reserve travel |3.1.6b| | 14 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 13 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 13 |
| Brakes imbalanced across an axle | 12 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 11 |
| Rear fog lamp not working |1.3.2b| | 11 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 11 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 11 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Windscreen has damage | 9 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 9 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 8 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 8 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 8 |
| Offside Stop lamp not working |1.2.1b| | 8 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 7 |
| Rear parking brake recording little or no effort | 7 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 7 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 6 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside front brake binding |3.7.B.1| | 6 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 6 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Rear Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 6 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 5 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 5 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 5 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Offside Front front brake binding |3.7.B.1| | 5 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 5 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 4 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Windscreen washer not working | 4 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside front brake binding |3.7.B.1| | 3 |
| Steering column top mounting bracket insecure |2.1.2d| | 3 |
| Emissions not tested |7.0| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 3 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 3 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear brake binding | 3 |
| Front brake application uneven | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Position lamp not working |4.2.1 |a|| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Headlamp aim out of alignment | 3 |