| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 28 |
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Headlamp aim out of alignment | 12 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Registration plate issues | 5 |
| Rear parking brake recording little or no effort | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 4 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Rear brake binding | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Offside Front Outer Front constant velocity joint is insecure |2.5.C.1b| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Steering rack insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Horn not working |1.6.2a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Parking brake operation is causing the vehicle to swerve to the nearside |3.7.C.3a| | 1 |
| Offside Front Steering column top bearing excessively worn |2.1.2c| | 1 |
| Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Brake cable has restricted free movement |1.1.15 |e|| | 1 |
| Brake cable has restricted free movement front to nearside rear |3.5.1k| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases flanges (6.1.2 (a)) | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Brake linkage has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Rear Passengers seat insecure both rearrests seats (6.2.6 (a) (ii)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Windscreen has damage | 1 |
| Front brake application uneven | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested overheating |7.3.A.1| | 1 |
| Brake pivot has restricted free movement |3.5.1k| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Outer Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Emissions unable to be completed due to exhaust leak (8.2.1.2 (d)) | 1 |
| Rear Headlamp levelling device inoperative snapped (4.1.5 (a)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Exhaust emissions likely to be affected by an exhaust leak front join (8.2.1.1 (b)) | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Rear Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment park brake test 12% minimum required 16% (1.1.6 (c)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush lower bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush lower bush (5.3.2 (c)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt gaiter insecure [ joint dry lost grease ] (6.1.7 (g) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases pipe from centre to rear exhaust missing (6.1.2 (a)) | 1 |
| Rear Exhaust silencer insecure joining pipe missing (8.1.1 (b) (i)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel system component leaking from union on lpg tank |7.2.3| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt gaiter insecure (6.1.7 (g) (ii)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill area (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill area in 2 places (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill area in 3 places (7.1.1 (a) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced arch / sill end (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced centrel inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced centrel inner sill x2 (7.1.1 (a) (i)) | 1 |
| Nearside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced centre sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Outer Suspension component mounting prescribed area is inadequately repaired centrel sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush advise has damaged sock casing / advise replace whole unit (5.3.2 (c)) | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Lower Steering column flexible coupling is excessively deteriorated (2.2.2 (c)) | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area is inadequately repaired wheel arch (7.1.1 (a) (i)) | 1 |
| Offside Rear Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Electronic stability control warning lamp indicates a fault VSC (7.12 (e)) | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn front drop link (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill corroded and holed (5.3.6 (a) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Corroded and holed at body mount behind OSF wheel (6.2.2 (d) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Wheel arch (7.1.1 (a) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Brake hose leaking at caliper |3.6.A.1| | 1 |
| Offside Front Brake hose leaking at caliper |3.6.A.1| | 1 |
| Nearside Front Brake pipe leaking at coiled pipe |3.6.A.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Suspension system inoperative |5.3.5 |a|| | 1 |
| Offside Front Suspension levelling valve damaged or deteriorated and function is seriously affected |5.3.5 |b| |ii|| | 1 |
| Emissions not tested |7.0| | 1 |