| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Brake pipe excessively corroded | 12 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear parking brake recording little or no effort | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Registration plate lamp issues | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Registration plate issues | 3 |
| Power steering fluid level below minimum |2.3.1| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Suspension system inoperative (5.3.5 (a)) | 2 |
| Parking brake: efficiency below requirements (3.7.B.7) | 2 |
| Horn not working (1.6.2a) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam electrical fault .turns off when ignition switched on |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill corroded from front to rear |6.2.2 |d| |i|| | 1 |
| Offside Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill corroded from front to rear |6.2.2 |d| |i|| | 1 |
| Offside Front Direction indicator not working wing repeater (4.4.1 (a) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Front Inner Anti-roll bar pin or bush excessively worn Middle "D" bushs (5.3.4 (a) (i)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Front Anti-roll bar linkage pin or bush excessively worn Both sides (5.3.4 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Offside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Central Rear Brake pipe connection leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer cv boot insicure (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired (6.2.2 (d) (ii)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn Both (5.3.4 (a) (i)) | 1 |
| Front Anti-roll bar linkage pin or bush excessively worn NS&OS (5.3.4 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen has damage | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Headlamp aim does not move downwards when dipped |British American headlamp| |1.8.C.4| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Front Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Rear Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Nearside Front Anti-lock braking system component missing |3.4.2| | 1 |
| Electrical wiring insecure negative battery terminal |1.9.2a| | 1 |
| Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Front Fluid suspension has no suspension movement |2.4.D.5| | 1 |
| Offside Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area fractured significantly reducing structural strength Sill area (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area fractured significantly reducing structural strength Sill area (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area fractured significantly reducing structural strength Sill area (5.3.6 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Rear Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wing (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wing (7.1.1 (a) (i)) | 1 |
| Headlamp levelling device inoperative switch faulty (4.1.5 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Central Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Rear Suspension pipe leaking (5.3.5 (c)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Brake pivot has restricted free movement |3.5.1k| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front wheel bearing has excessive play (2.5.A.3c) | 1 |
| Offside Rear Brake linkage has restricted free movement (3.5.1k) | 1 |
| Offside Front brake disc excessively scored (3.5.1h) | 1 |
| Nearside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Brake pedal anti-slip provision missing (3.3.A.1b) | 1 |
| Offside Front Front position lamp(s) not working (1.1.A.3b) | 1 |
| Power steering component(s) leaking (2.3.3b) | 1 |
| Brakes imbalanced across an axle | 1 |
| Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Brake drum back plate insecure & Corroded (1.1.14 (d)) | 1 |
| Offside Rear Brake drum back plate insecure & Corroded (1.1.14 (d)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Centre Brake lever has restricted free movement (3.5.1k) | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Nearside Rear Stop lamp not working (1.2.1b) | 1 |
| Power steering fluid level below minimum (2.3.1) | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Wheel Arch (6.1.B.2) | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Wheel Arch (6.1.B.2) | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2) | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded Sill (2.4.A.3) | 1 |
| Rear brake binding | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Passengers seat insecure Rearmost (6.2.6 (a) (ii)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Suspension component leaking Shock absorber (5.3.5 (c)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner to outer wheelarch (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner to outer wheelarch (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Rear of rear wheelarch, rearmost seat mount (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Rear of rear wheelarch, rearmost seat mount (7.1.1 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Steering rack has relative movement to chassis/bodywork steering rack bushes. (2.1.2 (a) (ii)) | 1 |
| Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Fuel tank insecure LPG tank |6.1.3 |a| |i|| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |