| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 45 |
| Registration plate lamp issues | 28 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 28 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Headlamp aim out of alignment | 16 |
| Parking brake lever has no reserve travel |3.1.6b| | 13 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 13 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Registration plate issues | 8 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 8 |
| Rear parking brake recording little or no effort | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 7 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 7 |
| Centre Exhaust system not adequately supported |7.1.1| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 6 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Brakes imbalanced across an axle | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear Brake pivot has restricted free movement |3.5.1k| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Brake hose excessively deteriorated | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Windscreen has damage | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 2 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Brake pivot has restricted free movement |3.5.1k| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Rear brake binding | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Exhaust has a major leak of exhaust gases At flexi |7.1.2| | 1 |
| Brake pivot has restricted free movement |3.5.1k| | 1 |
| Electrical wiring insecure At rear |1.9.2a| | 1 |
| Fuel pipe insecure At rear |7.2.1| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Drive shaft joint so worn it is likely to fail |6.1.7 |c| |ii|| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Central Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Centre Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Drag link end seriously misaligned |2.2.C.1b| | 1 |
| Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Parking brake operation is causing the vehicle to swerve to the nearside |3.7.C.3a| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting both rear wheel arches near seat belt heavily corroded and holed very weak (6.2.2 (d) (i)) | 1 |
| Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting both rear inner wing have corroded away no structure there (6.2.2 (d) (i)) | 1 |
| Rear Towbar excessively corroded within 30cm of towbar mounting tow bar bracket is heavily corroded and holed dangerous to use (6.1.6 (i) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn axle arm rear bush (5.3.4 (a) (i)) | 1 |
| Front Exhaust catalytic converter missing where one was fitted as standard (8.2.2.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake relay lever has restricted free movement |3.5.1k| | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn rear d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn REAR D BUSH (5.3.4 (a) (i)) | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering inner wheel arch |6.1.1 |c| |ii|| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Access panel cannot be secured in the closed position bonnet (6.2.1 (e)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn trailing arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Rear Parking brake operation grabbing severely |3.7.C.3b| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive 4.16 |7.3.D.4| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits 4.16 |8.2.1.2 |a|| | 1 |
| Nearside Fuel cap/sealing device missing |7.2.4a| | 1 |
| Dipswitch does not operate immediately when selected on main beam when dipped beam is on (4.1.3 (b)) | 1 |
| Front Wheel bearing has excessive play on both sides (5.1.3 (a) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Inner Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Inner Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Inner Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Inner Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Upper Body component corroded and likely to cause injury mounting (6.2.1 (a) (i)) | 1 |
| Offside Rear Upper Body component corroded and likely to cause injury body mounting (6.2.1 (a) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Drive shaft flexible coupling excessively deteriorated hub seal leaking excessively (6.1.7 (d) (i)) | 1 |
| Offside Front Drive shaft flexible coupling excessively deteriorated hub seal leaking excessively (6.1.7 (d) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting rearmost body/chassis mounting area corroded (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill corroded (6.2.2 (d) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill corroded (6.2.2 (d) (i)) | 1 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear brake caliper locking device missing |3.5.1l| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Stop lamp|s| not working In -op when position lamp on |4.3.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp obviously incorrectly positioned obscured by spare wheel |4.5.4 |a|| | 1 |
| Nearside Front Brake disc contaminated Hub seal leaking oil |1.1.14 |b|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Emission control equipment missing where fitted as standard CATALYST MISSING |8.2.1.1 |a|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Front Shock absorber detached |2.7.2b| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Brake pipe connection leaking on a hydraulic braking system OSF & NSR banjo on caliper (1.1.11 (b) (ii)) | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system Upper brake hose connection (1.1.11 (b) (ii)) | 1 |
| Front Headlamp light source and lamp not compatible Led bulbs in halogen lamps both front (4.1.4 (c)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect Both sides (4.1.2 (c)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Lower Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Headlamp light source and lamp not compatible both front halogen lamps have HID bulbs fitted |4.1.4 |c|| | 1 |
| Nearside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Rear Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Parking brake operation is causing the vehicle to swerve to the nearside not working |3.7.C.3a| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner and outer sill |5.2.6| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Centre Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |