| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 21 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 12 |
| Registration plate issues | 10 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Rear brake binding | 6 |
| Brake pipe excessively corroded | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Rear parking brake recording little or no effort | 4 |
| Horn not working |1.6.2a| | 4 |
| Rear Rear fog lamp not working |1.3.2b| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brake hose excessively deteriorated | 4 |
| Emissions not tested |7.0| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Headlamp aim out of alignment | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Windscreen has damage | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Brakes imbalanced across an axle | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Stub axle distorted |2.5.A.5b| | 1 |
| Offside Front Stub axle distorted |2.5.A.5b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Front brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Rear Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded inner and outer sill |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill and inner sill (7.1.1 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake hydraulic reservoir cap missing (1.1.10 (e)) | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Anti-roll bar pin or bush excessively worn both front (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Tie bar/rod locating pin insecure Bolt loose |2.4.G.3a| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush Anchor points to axle |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |8.2.1.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Front brake application uneven | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Rear Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Front Body component damaged and likely to cause injury wing mirror fixing (6.2.1 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Offside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Oil leaking excessively from transmission |8.4.1 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Rear Brake disc fractured (1.1.14 (a) (ii)) | 1 |
| Offside Rear Brake disc fractured (1.1.14 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Lower Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Rear Brake cable insecure | 1 |
| Offside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Centre Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Outer Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |