| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Registration plate lamp issues | 17 |
| Headlamp aim out of alignment | 17 |
| Brake pipe excessively corroded | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Rear parking brake recording little or no effort | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Rear brake binding | 4 |
| Brakes imbalanced across an axle | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Registration plate issues | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Central Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Brake pipe leaking on an air braking system compensator (1.1.11 (b) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Rear Seat belt missing middle lap belt |7.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Axle swivel joint insecure in a suspension arm |2.5.A.3b| | 1 |
| Offside Front Axle swivel joint insecure in a stub axle |2.5.A.3b| | 1 |
| Nearside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Exhaust system insecure middel box |6.1.2 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Front All position lamps not working and rear |1.1.A.3b| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits CO reading 1.03, default limit 0.5 (8.2.1.2 (b)) | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Passenger`s seat insecure centre row |6.2.A.1| | 1 |
| Offside Rear Outer Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced on axle |2.4.G.1| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded shock mount on axle |2.4.A.3| | 1 |
| Offside Body insecure and dangerous to other road users side step |6.1.B.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Brake valve insecurely mounted |3.6.A.2a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear fog lamp not working (1.3.2b) | 1 |
| Rear fog lamp switch missing (1.3.1a) | 1 |
| Rear fog lamp tell tale missing (1.3.1b) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.A.3) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light white light (4.5.4 (a)) | 1 |
| Parking brake operation is causing the vehicle to swerve to the nearside |3.7.C.3a| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |