Most common failures | No# failures |
---|
Registration plate lamp issues | 23 |
Brake pipe excessively corroded | 20 |
Headlamp aim out of alignment | 18 |
Rear parking brake recording little or no effort | 11 |
Parking brake: efficiency below requirements |3.7.B.7| | 11 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Registration plate issues | 7 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Rear Mechanical brake component has restricted free movement | 6 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Offside Rear fog lamp not working |1.3.2b| | 6 |
Brake hose excessively deteriorated | 5 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
Horn not working |1.6.2a| | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 5 |
Rear Rear fog lamp not working |1.3.2b| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 4 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front Direction indicator not working |1.4.A.2c| | 4 |
Rear brake binding | 4 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Rear fog lamp not working |1.3.2b| | 4 |
Rear Exhaust system not adequately supported |7.1.1| | 4 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Nearside Side repeater not working |1.4.A.2c| | 4 |
Brakes imbalanced across an axle | 4 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear Stop lamp not working |1.2.1b| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Side repeater not working |1.4.A.2c| | 3 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Nearside Front Braking system leaking |3.6.A.1| | 2 |
Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Emissions not tested |7.0| | 2 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Steering column shaft has excessive end float |2.1.3| | 2 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Side repeater incomplete |1.5.A1b| | 2 |
Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Offside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Brake valve leaking |3.6.A.1| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Central Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Front Brake pipe leaking |3.6.A.1| | 1 |
Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
Drag link end ball joint has excessive play loose in housing (2.1.3 (b) (i)) | 1 |
Steering box has relative movement between sector shaft and the drop arm relay unit after box (2.1.3 (a) (i)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Brake hose damaged | 1 |
Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
Nearside Front Battery insecure |1.9.1| | 1 |
Offside Front Battery insecure |1.9.1| | 1 |
Nearside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Front brake application uneven | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
Offside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Windscreen has damage | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Leaf spring shackle bracket fractured |2.4.B.6b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Nearside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
Offside Front Shock absorbers has an excessively worn bush top (5.3.2 (c)) | 1 |
Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Rear Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
Offside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Windscreen wiper blade insecure | 1 |
Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Fuel system component leaking fuel filter primer. |7.2.3| | 1 |
Rear reflector missing both |1.5.1a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
Offside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Front Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
Nearside Rear reflector insecure |1.5.1a| | 1 |
Offside Rear reflector insecure |1.5.1a| | 1 |
Centre Exhaust mounting missing |7.1.1b| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
An item not tested |Manual| | 1 |
Nearside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
Offside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Rear fog lamp insecure |1.3.2a| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Upper Leaf spring to axle securing nut missing |2.4.B.7b| | 1 |
Nearside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Outer Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Anti-roll bar missing |2.4.G.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Power steering pump drive system defective |2.3.6| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |