| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 20 |
| Headlamp aim out of alignment | 15 |
| Registration plate lamp issues | 11 |
| Brake pipe excessively corroded | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Registration plate issues | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Mechanical brake component has restricted free movement | 3 |
| Rear brake binding | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Windscreen has damage | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Brake hose damaged | 2 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Windscreen wiper blade insecure | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Front front brake juddering severely |3.7.A.2b| | 1 |
| An item not tested |Manual| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front Exhaust has a major leak of exhaust gases joint (6.1.2 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Emissions unable to be completed due to exhaust leaking (8.2.1.2 (d)) | 1 |
| Centre Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded INNER END SILL / REAR SPRING MOUNT |2.4.A.3| | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength END SILL |5.3.6 |a| |i|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength INNER END SILL |5.3.6 |a| |i|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength END SILL |5.3.6 |a| |i|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Steering wheel in a condition that hampers proper control |2.1.1| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Lower Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Tie bar/rod attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front brake application uneven | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |