| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 18 |
| Registration plate lamp issues | 17 |
| Headlamp aim out of alignment | 17 |
| Rear brake binding | 14 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Rear parking brake recording little or no effort | 13 |
| Brake hose excessively deteriorated | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Brakes imbalanced across an axle | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Registration plate issues | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Horn not working |1.6.2a| | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Lower Steering column universal joint has excessive play |2.1.5| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Windscreen washer not working | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Stop lamp not working |1.2.1b| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength 1nner and outer (5.3.6 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| Lower Universal Joint |2.2.A.1a| | 1 |
| Exhaust has a major leak of exhaust gases downpipe |7.1.2| | 1 |
| Steering pivot point has excessive play idler arm |2.2.B.1g| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Offside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Central Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction Mirror hanging |3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| showing white light to the rear |4.3.3 |a| |ii|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Under carpet and wheel arch |7.1.1 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Under carpet |7.1.1 |a| |i|| | 1 |
| Nearside Body mounting fixings insecure |6.2.2 |c| |i|| | 1 |
| Offside Body mounting fixings insecure |6.2.2 |c| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Central Exhaust system not adequately supported rear mount |7.1.1| | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Centre Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Offside Front Body panel insecure (6.2.1 (a) (i)) | 1 |
| Offside Rear Body panel insecure (6.2.1 (a) (i)) | 1 |
| Offside Front Position lamp has a product on the lens or light source which significantly reduces light intensity (4.2.3 (b) (ii)) | 1 |
| Steering column universal joint insecure to the extent there is excessive movement at the mountings |2.1.3 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Steering column universal joint is excessively deteriorated |2.1.5| | 1 |
| Rear Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Windscreen wiper blade insecure | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Windscreen has damage | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |