| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Registration plate lamp issues | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Registration plate issues | 3 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Emissions unable to be completed level to high (8.2.2.2 (e)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill corroded (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill corroded (7.1.1 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake pedal anti-slip provision missing and damaged (1.1.2 (c)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine falling onto the exhaust system (8.4.1 (a) (i)) | 1 |
| Front Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Rear Seat belt not functioning as intended centre (7.1.2 (c)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Towbar attachment insecure hitch loose (6.1.6 (c) (i)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Emissions not tested exhaust back box broken off (8.2.1.2 (d)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength mark in yellow (5.3.6 (a) (i)) | 1 |
| Front Bumper likely to become detached (6.1.4 (a) (ii)) | 1 |
| Trailer electrical socket likely to become detached (4.10 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear reflector reflecting white to the rear both sides rear (4.8.2 (a) (ii)) | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering Front panel corroded - anti-roll bar mounting prescribed area |6.1.A.1| | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Towing eyes |6.1.B.2| | 1 |
| Stop lamp(s) not working high level (4.3.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn swinging shackle (5.3.4 (a) (i)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust particulate filter missing where one was fitted as standard |7.1.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre mounting area (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre mounting area (6.2.2 (d) (i)) | 1 |
| Exhaust has a major leak of exhaust gases main silencer (6.1.2 (a)) | 1 |
| Fuel tank insecure one strap broken, one strap cracked (6.1.3 (a) (i)) | 1 |
| Central Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting one nearside and two offside central mounting areas corroded (6.2.2 (d) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |