Most common failures | No# failures |
---|
Registration plate lamp issues | 15 |
Headlamp aim out of alignment | 13 |
Brake pipe excessively corroded | 12 |
Parking brake: efficiency below requirements |3.7.B.7| | 11 |
Rear fog lamp not working |1.3.2b| | 10 |
Windscreen wiper does not clear the windscreen effectively | 10 |
Brakes imbalanced across an axle | 7 |
Offside Stop lamp not working |1.2.1b| | 6 |
Offside Rear fog lamp not working |1.3.2b| | 6 |
Rear parking brake recording little or no effort | 6 |
Rear brake binding | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Steering rack insecure |2.2.B.1a| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Brake hose excessively deteriorated | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Nearside Rear reflector missing |1.5.1a| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
Registration plate issues | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 2 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 2 |
Steering box has a significant oil leak |2.2.D.2e| | 2 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Rear fog lamp missing |1.3.2a| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Horn not working |1.6.2a| | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Mechanical brake component has restricted free movement | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Emissions not tested Bank 2 |7.3.A.1| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Offside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
Nearside Rear Rear reflector missing |1.5.1a| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
Parking brake operation is causing the vehicle to swerve to the nearside Offside handbrake lever seized / brake binding |3.7.C.3a| | 1 |
Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Centre Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Nearside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Offside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Front Shock absorber detached |2.7.2b| | 1 |
Rear brake application uneven | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Steering arm has relative movement at its fixings drop arm on steering box lower joint |2.2.B.1h| | 1 |
Brake linkage has restricted free movement parking brake linkage |3.5.1k| | 1 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill on cab |6.1.B.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings in wheel arch where front most body mount is located |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings rear of cab beside seatbelt mounting point |6.1.B.2| | 1 |
Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced body mounting on cabs rearmost mounting (6.1.1 (c) (i)) | 1 |
Nearside Rear Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
Offside Rear Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body sill next to body mounts (6.2.2 (d) (i)) | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body sill next to body mounts (6.2.2 (d) (i)) | 1 |
Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired all rear body mounts (6.2.2 (d) (ii)) | 1 |
Steering component mounting prescribed area so damaged that control of the vehicle is likely to be adversely affected mount for steering box (2.1.2 (e) (ii)) | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
Centre Drive shaft which forms part of the suspension support bearing excessively worn |2.4.G.4d| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Power steering pump drive system defective |2.3.6| | 1 |
Nearside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Drag link end ball pin shank loose |2.2.B.1c| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Steering rack insecure nearside and offside mounting bushes worn |2.2.B.1a| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Brake hose excessively damaged |3.6.B.4d| | 1 |
Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Intermediate drop arm insecure |2.2.B.1a| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Windscreen wiper blade insecure | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Rear fog lamp tell-tale not working no tell tale light illuminating on switch or dash (4.9.1 (a) (ii)) | 1 |
Rear fog lamp missing |1.3.2a| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Central Rear Body has a sharp edge caused by corrosion tailgate |6.1.C.1| | 1 |
Nearside Rear Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Central Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings crossmember |6.1.B.2| | 1 |
Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Exhaust has a major leak of exhaust gases back box
|7.1.2| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Nearside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Offside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Rear fog lamp does not face the rear |1.3.2a| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering system fouling |2.2.D.2a| | 1 |