| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Registration plate lamp issues | 11 |
| Brake pipe excessively corroded | 11 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear brake binding | 6 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Registration plate issues | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Brakes imbalanced across an axle | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Front brake disc contaminated by grease |3.5.1h| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Brake hose excessively deteriorated | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Centre Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
| Offside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Offside Front Drag link end loose |2.2.B.1d| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Front Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Centre Brake cable locking device missing |3.5.1l| | 1 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Lower Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Leaf spring shackle bracket loose rear |2.4.B.6a| | 1 |
| Offside Front Lower Axle swivel joint insecure in a stub axle bolt loose |2.5.A.3b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front All position lamps not in good working order |function impaired| |1.1.A.2a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Needs re clipping (6.1.7 (g) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Centre Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Intermediate drop arm damaged and unserviceable |2.2.C.1d| | 1 |
| Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Nearside Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Drag link end loose |2.2.B.1d| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |