| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Headlamp aim out of alignment | 16 |
| Brake pipe excessively corroded | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Rear parking brake recording little or no effort | 8 |
| Registration plate lamp issues | 8 |
| Horn not working |1.6.2a| | 7 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 7 |
| Brakes imbalanced across an axle | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Rear brake binding | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 3 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Rear brake application uneven | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Registration plate issues | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside Rear front brake binding |3.7.B.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 2 |
| Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Upper Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Upper Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen has damage | 1 |
| Vehicle Identification Number not legible |6.3.5.a| | 1 |
| Nearside Front Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Central Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear reflector missing |1.5.1a| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Brake modification unsafe handbrake cable (1.1.21 (d) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Stop lamp(s) adversely affected by the operation of another lamp Stop and tail bulb incorrectly fitted (4.3.3 (b)) | 1 |
| Offside Rear Brake drum contaminated (1.1.14 (b)) | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced upper sill corroded |7.1.1 |a| |i|| | 1 |
| Nearside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Front Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Front brake application uneven | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Central Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake cable insecure |3.5.1d| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Horn control missing |1.6.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |