| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 19 |
| Registration plate lamp issues | 14 |
| Rear parking brake recording little or no effort | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Brakes imbalanced across an axle | 9 |
| Registration plate issues | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Headlamp aim out of alignment | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 4 |
| Horn not working |1.6.2a| | 4 |
| Rear brake application uneven | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Exhaust engine idle speed too high |7.3.A.2a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 2 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear brake binding | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement rearward |2.4.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Upper Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
| Offside Front Brake hose stretched |3.6.B.4c| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Brake pipe inadequately supported engine bay near servo |3.6.B.1| | 1 |
| Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Windscreen has damage | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
| Nearside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake pedal excessively corroded |3.3.A.1a| | 1 |
| Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Outer Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear Upper Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Front brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Horn control missing |1.6.1| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Steering column attachment defective to the extent that there is a serious risk of detachment pinch bolt missing |2.2.2 |d| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Emissions not tested |7.0| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Leaf spring anchor bracket bolt missing |2.4.B.6c| | 1 |
| Offside Rear Leaf spring anchor bracket bolt missing |2.4.B.6c| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Nearside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Nearside Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Offside Rear Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Front Steering box insecure |2.2.B.1a| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Stub axle distorted |2.5.A.5b| | 1 |
| Offside Front Stub axle distorted |2.5.A.5b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Power steering component|s| leaking |2.3.3b| | 1 |