| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 9 |
| Horn not working |1.6.2a| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Windscreen washer not working | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear brake binding | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear brake application uneven | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Nearside Seat belt missing (7.1.2 (a)) | 1 |
| Offside Seat belt missing (7.1.2 (a)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Front Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Nearside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Offside Rear Fuel hose insecure Fuel tank hose. (6.1.3 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded Sill |5.2.6| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Drivers floor |6.1.B.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Rear Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside An item not tested |Manual| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Front Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Centre Rear Exhaust mounting missing |7.1.1b| | 1 |
| Centre Front Exhaust mounting missing |7.1.1b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Registration plate issues | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake linkage locking device insecure |3.5.1l| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Brake pipe excessively corroded | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Exhaust silencer insecure |8.1.1 |b| |i|| | 1 |
| Rear Exhaust silencer likely to become detached |8.1.1 |b| |ii|| | 1 |
| Exhaust emissions - engine idle speed too high |8.2.1.2 |e|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Floor excessively deteriorated inner arch corroded near body mount |6.2.4 |a| |i|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Seat belt insecurely fixed to the vehicles structure both front buckles |5.2.1a| | 1 |