| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Brake hose excessively deteriorated | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Headlamp aim out of alignment | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Outer Fuel pipe damaged central pipe rubber damaged (6.1.3 (c) (ii)) | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Trailer electrical socket wiring insulation damaged or deteriorated and likely to cause a short-circuit (4.10 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases cat to centre pipe joint (6.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Inner Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases prope going into cat corroded, broken away in cat (6.1.2 (a)) | 1 |
| Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength o/s&n/s near radiator (5.3.6 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Rear Exhaust system insecure silencer (6.1.2 (a)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Windscreen washer not working | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Windscreen wiper not working both (3.4 (a)) | 1 |
| Central Exhaust system insecure hanger corroded off (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Emissions unable to be completed overheating (8.2.1.2 (d)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired inner sill (5.3.6 (a) (i)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Front Exhaust has a major leak of exhaust gases cat/centre flange (6.1.2 (a)) | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases cat flange (6.1.2 (a)) | 1 |