| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 20 |
| Brake hose excessively deteriorated | 10 |
| Brake pipe excessively corroded | 9 |
| Brakes imbalanced across an axle | 7 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Headlamp aim out of alignment | 4 |
| Registration plate lamp issues | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 3 |
| Registration plate issues | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear fog lamp not working (1.3.2b) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Headlamp aim projected beam image is obviously incorrect Both (4.1.2 (c)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brake hose damaged | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Shock absorber has a serious fluid leak (2.7.3) | 1 |
| Offside front brake binding (3.7.B.1) | 1 |
| Nearside Steering lock stop incorrectly adjusted (2.2.D.2c) | 1 |
| Offside Steering lock stop incorrectly adjusted (2.2.D.2c) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front brake disc excessively pitted (3.5.1h) | 1 |
| Offside Front brake disc excessively pitted (3.5.1h) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced corroded (7.1.1 (a) (i)) | 1 |
| Offside Front Anti-roll bar ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Rear Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front Oil leaking excessively from transmission transmision pipe (8.4.1 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens which changes emitted colour to other than white or yellow (4.1.4 (b)) | 1 |
| Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Nearside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear Outer Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases backbox (6.1.2 (a)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Rear Spare wheel insecure in carrier (6.1.5 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch marked in yellow chalk (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill holed and corroded marked in yellow chalk (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill behind step corroded yellow chalk (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced holed and corroded at exhaust marked in yellow chalk (6.1.1 (c) (i)) | 1 |
| Nearside Body panel likely to become detached Side step (6.2.1 (a) (ii)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Chalked (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Floor/side step corroded (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chalked (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chalked (6.1.1 (c) (i)) | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Offside Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Rear fog lamp switch insecure (4.5.3 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Windscreen washer not working | 1 |
| Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Anti-roll bar has excessive play in a pin/bush both front D-bushes |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Central Rear Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Emissions not tested due to exhaust leak (8.2.2.2 (e)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Outer Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre An item not tested |Manual| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Rear Spare wheel carrier insecure |6.4.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp does not face the rear (4.5.4 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Vehicle structure fractured seriously affecting its strength within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Front Headlamp lens seriously defective x2 (4.1.1 (b) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |