| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Brake pipe excessively corroded | 9 |
| Registration plate lamp issues | 7 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 6 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Registration plate issues | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Headlamp aim out of alignment | 5 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Centre Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Rear brake binding | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Steering locking device missing Track rod split pin. (2.1.3 (d)) | 1 |
| Nearside Steering locking device missing Ball joint split pin. (2.1.3 (d)) | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen bulb insecure |4.1.2 |a|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect lens faded resulting in no beam image (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect lens faded resulting in no beam image (4.1.2 (c)) | 1 |
| Nearside Front Headlamp lens seriously defective lens faded resulting in no beam image (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective lens faded resulting in no beam image (4.1.1 (b) (ii)) | 1 |
| Offside Lower Engine mounting bracket excessively loose bolt missing (6.1.8 (a) (ii)) | 1 |
| Offside Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting inner sill (6.1.6 (i) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush top mount/bush (5.3.2 (c)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Nearside Rear Fuel hose excessively chafed Tank Hose Chafed On Parking Brake Outer Cable. |7.2.2| | 1 |
| Offside Outer engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Parking brake efficiency below requirements |3.7.E.1| | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
| Exhaust has a major leak of exhaust gases center section and back box (6.1.2 (a)) | 1 |
| Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt both |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Centre Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Windscreen wiper blade missing |8.2.2| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect Advise polish |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect Advise polish |1.8.A.1b| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Upper engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement prop shaft |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Steering locking device missing (2.1.3 (d)) | 1 |
| Offside Front Steering locking device missing (2.1.3 (d)) | 1 |
| Offside Front Rear fog lamp switch faulty |1.3.1a| | 1 |
| Central Front Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive missfiring, |7.3.D.3| | 1 |
| Front brake application uneven | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced full of water |1.7.5a| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |