| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 33 |
| Windscreen wiper does not clear the windscreen effectively | 31 |
| Parking brake: efficiency below requirements |3.7.B.7| | 17 |
| Brake pipe excessively corroded | 11 |
| Rear parking brake recording little or no effort | 10 |
| Registration plate issues | 9 |
| Headlamp aim out of alignment | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Brakes imbalanced across an axle | 6 |
| Rear brake application uneven | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Rear brake binding | 3 |
| Windscreen has damage | 3 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Offside Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Obligatory mirror insecure |8.1.1| | 2 |
| Steering column universal joint has excessive play |2.1.5| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced arch (7.1.1 (a) (i)) | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush d bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush d bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush bush |2.4.G.2| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced Excessive corrosion at drivers seatbelt anchorage (7.1.1 (a) (i)) | 1 |
| Nearside Front Inner Body modification likely to adversely affect braking or steering wing |6.2.1 |d| |ii|| | 1 |
| Offside Front Inner Body modification likely to adversely affect braking or steering wing |6.2.1 |d| |ii|| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded door panel |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded door panel |5.2.6| | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view glass broken |3.3 |b| |ii|| | 1 |
| Offside Rear Leaf spring fractured |5.3.1 |b| |i|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected lense broken |4.4.1 |b| |ii|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced arch/door shut area |7.1.1 |a| |i|| | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Front Outer Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Outer Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn end (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn end (5.3.4 (a) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Lower Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Cab steps in such a condition that it is likely to cause injury (6.2.8 (b)) | 1 |
| Offside Cab steps in such a condition that it is likely to cause injury (6.2.8 (b)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings tipper body pivots |6.1.B.2| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Seat belt anchorage likely to become detached in the event of a collision |7.1.1 |a| |ii|| | 1 |
| Offside Seat belt anchorage likely to become detached in the event of a collision |7.1.1 |a| |ii|| | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Brake performance not tested due to leak (1.2.1 (g)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced arch (7.1.1 (a) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded floor (2.1.2 (e) (i)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced x2 (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired chassis (7.1.1 (a) (i)) | 1 |
| Lower Steering column universal joint likely to become detached to steering rack (2.1.3 (a) (ii)) | 1 |
| Nearside Front Integral body structure has excessive corrosion which adversely affects braking or steering cab chassie rails corroded (6.1.1 (c) (ii)) | 1 |
| Offside Integral body structure has excessive corrosion which adversely affects braking or steering cab frour chassie rails (6.1.1 (c) (ii)) | 1 |
| Nearside Front Integral body structure has excessive corrosion which adversely affects braking or steering inner step (6.1.1 (c) (ii)) | 1 |
| Offside Rear Position lamp not working side lamp out (4.2.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step (7.1.1 (a) (i)) | 1 |
| Emissions not tested excessive smoke (8.2.2.2 (e)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded under step |2.4.A.3| | 1 |
| Front Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement both bushs |2.4.G.2| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing |6.1.B.2| | 1 |
| Offside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Emissions not tested excessive smoke |7.3.A.1| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened as marked (5.3.3 (b) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced arch as marked (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door step as marked (6.1.1 (c) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced arch/step x2 (7.1.1 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering column universal joint insecure to the extent there is excessive movement at the mountings |2.1.3 |a| |ii|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced sill/step |7.1.1 |a| |i|| | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Front Driver`s seat insecure |6.2.A.1| | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Front brake application uneven | 1 |