| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Registration plate issues | 6 |
| Brake hose excessively deteriorated | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Brake hose has insufficient room to move | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Registration plate lamp issues | 3 |
| Offside Front Coil spring not correctly located |2.4.C.2| | 3 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear brake binding | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 2 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Speedometer cannot be illuminated. |6.7.3| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Coil spring not correctly located |2.4.C.2| | 2 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Nearside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Brake pipe excessively corroded | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded tie bar |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner tiebar |2.4.A.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired floor |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired floor |5.2.6| | 1 |
| Nearside Inner Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Inner Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Nearside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
| Steering linkage ball joint has excessive play steering box drop link ball joint (2.1.3 (b) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Inner Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Outer Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Outer Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Inner Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Mechanical brake component securing device missing |3.5.1i| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Centre Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Inner Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on ns not working |1.4.B.1f| | 1 |
| Nearside Outer Steering retaining device missing track rod ball joint |2.2.C.1g| | 1 |
| Nearside Inner Steering retaining device missing track rod ball joint |2.2.C.1g| | 1 |
| Offside Outer Steering retaining device missing track rod ball joint |2.2.C.1g| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Steering box has excessive free play detected at the steering wheel |steering box fitted| steering arm bush |2.3 |a| |i|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |