| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 2068 |
| Registration plate lamp issues | 2007 |
| Windscreen wiper does not clear the windscreen effectively | 1769 |
| Brake pipe excessively corroded | 667 |
| Brakes imbalanced across an axle | 530 |
| Rear brake binding | 526 |
| Front brake disc in such a condition that it is seriously weakened | 445 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 392 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 384 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 383 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 383 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 373 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 354 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 350 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 347 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 347 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 327 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 299 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 295 |
| Registration plate issues | 294 |
| Nearside Stop lamp not working |1.2.1b| | 289 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 288 |
| Offside Stop lamp not working |1.2.1b| | 281 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 276 |
| Parking brake: efficiency below requirements |3.7.B.7| | 271 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 257 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 255 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 252 |
| Rear parking brake recording little or no effort | 202 |
| Hazard warning switch faulty |1.4.B.1d| | 200 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 190 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 187 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 175 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 173 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 172 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 168 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 148 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 135 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 129 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 127 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 123 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 119 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 112 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 109 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 108 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 108 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 108 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 107 |
| Anti-lock braking system warning lamp indicates an ABS fault | 105 |
| Offside Rear Stop lamp not working |1.2.1b| | 103 |
| Parking brake lever has no reserve travel |3.1.6b| | 98 |
| Nearside Rear Stop lamp not working |1.2.1b| | 96 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 95 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 93 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 91 |
| Offside Front Position lamp not working |4.2.1 |a|| | 91 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 90 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 88 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 87 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 87 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 87 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 85 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 85 |
| Rear Exhaust system not adequately supported |7.1.1| | 85 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 84 |
| Hazard warning lamps inoperative |1.4.B.1b| | 84 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 83 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 82 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 81 |
| Horn not working (7.7 (a)) | 81 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 80 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 79 |
| Windscreen washer not working | 79 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 77 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 76 |
| Horn not working |1.6.2a| | 76 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 75 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 75 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 74 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 71 |
| Emissions not tested (8.2.1.2 (d)) | 71 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 70 |
| Front brake excessively fluctuating | 70 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 69 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 67 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 66 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 66 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 65 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 65 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 63 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 63 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 63 |
| Exhaust system not adequately supported |7.1.1| | 63 |
| Front brake application uneven | 60 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 60 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 60 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 59 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 58 |
| Rear Mechanical brake component has restricted free movement | 58 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 56 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 55 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 55 |
| Electronic power steering warning lamp indicates a failure in the system |2.3.8| | 53 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 52 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 52 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 51 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 51 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 50 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 50 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 50 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 48 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 47 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 47 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 47 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 47 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 47 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 44 |
| Power steering inoperative |2.3.3a| | 44 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 43 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 43 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 43 |