| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 56 |
| Registration plate lamp issues | 32 |
| Windscreen wiper does not clear the windscreen effectively | 32 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 15 |
| Registration plate issues | 13 |
| Brake pipe excessively corroded | 9 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Centre Stop lamp not working |1.2.1b| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Front brake application uneven | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Brake pedal fouling on other parts of the vehicle |3.3.A.4| | 1 |
| Offside Rear Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Outer Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Front Anti-lock braking system wiring excessively damaged |3.4.3| | 1 |
| Offside Front Anti-lock braking system wiring excessively damaged |3.4.3| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Supplementary restraint system warning lamp indicates a fault air bag light on (7.1.6 (a)) | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Brake pipe seriously damaged |found during steering lock to lock check| to rear inner wheelarch |2.2.D.2b| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Upper Steering column universal joint has excessive play |2.1.5| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Front Steering retaining device missing |2.2.C.1g| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt nearside & offside |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear Lower Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Fuel cap/sealing device missing LPG cap missing |6.1.3 |b| |i|| | 1 |
| Rear brake binding | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Inner Parking brake lever has no reserve travel pads |3.1.6b| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Central Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Upper Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Upper Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Front position lamp|s| not working both fronts |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Inner Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Anti-roll bar linkage inappropriately repaired |2.4.A.2| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Position lamp not working Side (4.2.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working Side (4.2.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Rear Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Sub-frame attachment bracket/mounting fractured SUB FRAME CORRODED AND BROKEN |5.3.3 |b| |ii|| | 1 |
| Nearside Rear Parking brake inoperative on one side VERT WEAK |1.4.1 |a|| | 1 |
| Offside Front Suspension arm fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |