| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 84 |
| Windscreen wiper does not clear the windscreen effectively | 70 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 51 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 36 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 35 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 31 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 26 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 22 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 22 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 21 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 21 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 21 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 20 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 18 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 18 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 14 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 14 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 14 |
| Registration plate lamp issues | 14 |
| Brake pipe excessively corroded | 13 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 13 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 11 |
| Windscreen washer not working | 10 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 10 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 9 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 9 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 9 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 9 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Horn not working (7.7 (a)) | 8 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 8 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 8 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 8 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 7 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 7 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 7 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 7 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 6 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 6 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Registration plate issues | 6 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 5 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 5 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Offside Rear Shock absorbers has a serious fluid leak | 5 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 5 |
| Brakes imbalanced across an axle | 5 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Steering rack insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 4 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 4 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 4 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 4 |
| Emissions unable to be completed (8.2.1.2 (d)) | 4 |
| Central Rear Seat belt missing (7.1.2 (a)) | 4 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 4 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 3 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 3 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 3 |
| Nearside Front Bumper insecure (6.1.4 (a) (i)) | 3 |
| Offside Front Headlamp aim unable to be tested (4.1.2 (b)) | 3 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Offside Rear Outer Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 3 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 3 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 3 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Headlamp light intensity severely reduced both (4.1.4 (a)) | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 2 |
| Offside Rear Inner Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Front Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Rear fog lamp likely to become detached (4.5.1 (c) (ii)) | 2 |
| Offside Outer Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Outer Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Inner Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 2 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 2 |
| Nearside Rear Inner Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Rear fog lamp switch missing (4.5.3 (a)) | 2 |
| Front Headlamp has a product on the lens so that the light output is severely reduced both (4.1.4 (b)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Split (6.1.7 (g) (ii)) | 2 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 2 |
| Nearside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 2 |
| Emissions unable to be completed (8.2.2.2 (e)) | 2 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |