| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Brakes imbalanced across an axle | 5 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 3 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 2 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Rear fog lamp switch missing (4.5.3 (a)) | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Registration plate lamp issues | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn both (5.1.2 (b) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Seat belt installation has a claw type seat mounting with an inadequate means of securing the claw (10.1 (o)) | 1 |
| Offside Front Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Headlamp has a product on the light source so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Rear fog lamp light intensity significantly reduced |4.5.4 |a|| | 1 |
| Offside Front Anti-roll bar ball joint dust cover missing |5.3.4 |b| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Central Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| rack bushes |2.3 |a| |i|| | 1 |
| Rear fog lamp light intensity significantly reduced Not showing red light to rear |4.5.4 |a|| | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced Both |4.1.4 |b|| | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Steering rack has relative movement to chassis/bodywork |2.1.2 |a| |ii|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Central Rear Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn axle bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn axle bush (5.3.4 (a) (i)) | 1 |
| Rear Exhaust silencer insecure bolts and springs missing (8.1.1 (b) (i)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Track rod end ball joint has excessive play Both (2.1.3 (b) (i)) | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Front Suspension component ball joint dust cover no longer prevents the ingress of dirt both (5.3.4 (b) (ii)) | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Steering rack insecure bushes badly worn. excess movement (2.1.3 (a) (i)) | 1 |
| Rear Sub-frame pin or bush excessively worn both n/s and o/s (5.3.4 (a) (i)) | 1 |
| Axle insecure such that functionality is affected rear diff foreward mount worn to excess (5.1.1 (b) (ii)) | 1 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Stop lamp(s) emits other than a steady red light high level (4.3.3 (a) (ii)) | 1 |
| Central Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-lock braking system wheel speed sensor excessively damaged (1.6 (c)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt lower rubber |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt both rubbers |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Power steering component leaking Hose connecting to rack leaking (2.1.5 (a)) | 1 |
| Offside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Front Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Rear fog lamp does not emit a steady red light lost colour |4.5.4 |a|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear fog lamp emits a light other than red lost colour |1.3.2e| | 1 |
| Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt offside and nearside front lower joints |2.4.G.2| | 1 |
| Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt offside and nearside fronts |2.4.G.2| | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt upper and lower dust covers |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Radius arm rubber bush bonding deteriorated resulting in excessive movement axle bush |2.4.G.2| | 1 |
| Offside Rear Radius arm synthetic bush deteriorated resulting in excessive movement axle bush |2.4.G.2| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Chassis/Box Section(Marked) (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Chassis/Box Section(Marked) (7.1.1 (a) (i)) | 1 |
| Rear Exhaust system insecure Snapped At Box Entry (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases Snapped At Box Entry (6.1.2 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |