| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Rear parking brake recording little or no effort | 11 |
| Brakes imbalanced across an axle | 9 |
| Parking brake lever has no reserve travel |3.1.6b| | 8 |
| Registration plate issues | 7 |
| Registration plate lamp issues | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Brake hose has insufficient room to move | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Horn not working |1.6.2a| | 3 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear reflector missing |1.5.1a| | 2 |
| Offside Rear reflector missing |1.5.1a| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Windscreen washer not working | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Exhaust system not adequately supported silencer loose |7.1.1| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| Parking brake operation is causing the vehicle to swerve to the offside |3.7.C.3a| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
| Nearside Front Lower Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Lower Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Lower Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) play on rack (2.3 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Dipswitch does not operate immediately when selected on dipped beam (4.1.3 (b)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Offside Rear Panhard rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Front suspension locking device ineffective |2.5.A.4| | 1 |
| Offside Front Lower Front suspension locking device ineffective |2.5.A.4| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Front Front suspension retaining device ineffective |2.5.A.4| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Nearside Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Stop lamp not working both side |1.2.1b| | 1 |
| Nearside Rear Lower Suspension has inadequate clearance with the chassis trailing arm |2.4.A.1a| | 1 |
| Offside Rear Lower Suspension has inadequate clearance with the chassis trailing arm |2.4.A.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Front passenger seat insecure |6.2.3| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Rear Service brake effort inadequate at a wheel o/s rear brake effort to low on service and hand brake (1.2.1 (a) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp not working on main beam (1.7.5a) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear brake binding | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |