Most common failures | No# failures |
---|
Headlamp aim out of alignment | 19 |
Windscreen wiper does not clear the windscreen effectively | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Brake pipe excessively corroded | 5 |
Registration plate lamp issues | 5 |
Brakes imbalanced across an axle | 4 |
Registration plate issues | 4 |
Rear parking brake recording little or no effort | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front Headlamp insecure |1.7.3| | 3 |
Battery insecure |1.9.1| | 3 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Windscreen washer not working | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Front Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Central Front Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
Offside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Rear fog lamp insecure |1.3.2a| | 1 |
Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Exhaust has a part missing |7.1.1a| | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Nearside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired in front and behind spring mounting area [chalked] (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired in front and behind spring mounting area [chalked] (5.3.6 (a) (i)) | 1 |
Offside Front Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Body panel insecure (6.2.1 (a) (i)) | 1 |
Offside Rear Body panel damaged and likely to cause injury (6.2.1 (a) (i)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Offside Rear Shock absorbers has a serious fluid leak | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced doorstep area (7.1.1 (a) (i)) | 1 |
Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Brake pipe leaking along chassis leg |3.6.A.1| | 1 |
Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Offside Front Inner Seat belt anchorage prescribed area is excessively corroded jacking point |5.2.6| | 1 |
Nearside Front Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Central Brake pipe inadequately supported front to rear |3.6.B.1| | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength rear mounting (5.3.6 (a) (i)) | 1 |
Brake hose excessively deteriorated | 1 |
Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Windscreen has damage | 1 |
Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Trailer electrical socket insecure |1.9.3a| | 1 |
Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering fluid level below minimum |2.3.1| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Mechanical brake component has restricted free movement | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Centre Rear Brake hose leaking |3.6.A.1| | 1 |
Power steering pump insecure |2.3.6| | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Horn not working |1.6.2a| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Coil spring not correctly located |2.4.C.2| | 1 |
Nearside Front Suspension arm locating pin insecure |2.4.G.3a| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |