| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 853 |
| Brake pipe excessively corroded | 781 |
| Registration plate lamp issues | 773 |
| Windscreen wiper does not clear the windscreen effectively | 638 |
| Brakes imbalanced across an axle | 355 |
| Rear brake binding | 265 |
| Service brake: efficiency below requirements |3.7.B.7| | 258 |
| Parking brake: efficiency below requirements |3.7.B.7| | 223 |
| Exhaust system not adequately supported |7.1.1| | 212 |
| Brake hose excessively deteriorated | 180 |
| Battery insecure |1.9.1| | 143 |
| Offside Rear fog lamp not working |1.3.2b| | 132 |
| Rear parking brake recording little or no effort | 131 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 122 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 119 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 118 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 111 |
| Windscreen washer not working | 110 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 100 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 96 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 94 |
| Horn not working |1.6.2a| | 92 |
| Front brake disc in such a condition that it is seriously weakened | 91 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 91 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 89 |
| Nearside Stop lamp not working |1.2.1b| | 87 |
| Offside Headlamp not working on main beam |1.7.5a| | 87 |
| Offside Stop lamp not working |1.2.1b| | 87 |
| Registration plate issues | 85 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 83 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 78 |
| Rear brake application uneven | 78 |
| Offside Side repeater not working |1.4.A.2c| | 76 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 71 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 70 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 67 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 67 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 65 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 64 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 63 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 59 |
| Rear fog lamp not working |1.3.2b| | 57 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 57 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 57 |
| Rear Exhaust system not adequately supported |7.1.1| | 55 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 51 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 50 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 49 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 49 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 48 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 48 |
| Nearside Side repeater not working |1.4.A.2c| | 48 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 47 |
| Nearside Headlamp insecure |1.7.3| | 46 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 46 |
| Offside Headlamp insecure |1.7.3| | 44 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 44 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 44 |
| Exhaust system insecure (6.1.2 (a)) | 43 |
| Nearside Headlamp not working on main beam |1.7.5a| | 43 |
| Centre Exhaust system not adequately supported |7.1.1| | 43 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 43 |
| Brake load sensing valve linkage seized |3.6.E.3| | 42 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 42 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 41 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 41 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 40 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 40 |
| Nearside Rear Stop lamp not working |1.2.1b| | 39 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 39 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 39 |
| Offside Rear Stop lamp not working |1.2.1b| | 38 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 38 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 37 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 37 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 37 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 36 |
| Exhaust mounting missing |7.1.1b| | 36 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 35 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 35 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 35 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 35 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 34 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 34 |
| Offside Front brake disc excessively pitted |3.5.1h| | 33 |
| Emissions not tested |7.0| | 33 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 33 |
| Rear Mechanical brake component has restricted free movement | 33 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 33 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 33 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 32 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 32 |
| Centre Exhaust mounting missing |7.1.1b| | 32 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 32 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 32 |
| Front brake application uneven | 31 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 31 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 31 |
| Parking brake lever has no reserve travel |3.1.6b| | 31 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 30 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 29 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 29 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 28 |
| Brake load sensing valve seized |3.6.E.3| | 28 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 27 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 27 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 27 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 27 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 27 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 26 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 26 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 25 |
| Horn not working (7.7 (a)) | 25 |
| Rear Exhaust mounting missing |7.1.1b| | 25 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 25 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 25 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 24 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 24 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 24 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 23 |
| Offside Front Direction indicator not working |1.4.A.2c| | 23 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 23 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 23 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 23 |
| Driver`s seat insecure |6.2.A.1| | 23 |
| Offside Steering rack gaiter split |2.2.D.2d| | 23 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 22 |
| Front brake disc excessively pitted |3.5.1h| | 22 |
| Brake performance not tested |3.7.A.1| | 22 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 22 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 22 |
| All position lamps not working |1.1.A.3b| | 22 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 22 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 22 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 21 |
| Nearside Headlamp insecure (4.1.1 (c)) | 21 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 21 |
| Front brake excessively fluctuating | 21 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 21 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 21 |
| Offside Front Side repeater not working |1.4.A.2c| | 21 |
| Windscreen has damage | 21 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 20 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 20 |
| Windscreen wiper blade insecure | 20 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 20 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 20 |
| Windscreen wiper not working (3.4 (a)) | 19 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 19 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 19 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 19 |
| Offside Headlamp insecure (4.1.1 (c)) | 18 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 18 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 18 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 18 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 18 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 18 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 18 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 18 |
| Rear fog lamp tell tale not working |1.3.1b| | 18 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 17 |
| Brake hose damaged | 17 |
| Exhaust has a part missing |7.1.1a| | 17 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 17 |
| Horn not working |7.7 |a| |ii|| | 17 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 17 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 17 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 17 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 16 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 16 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 16 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 16 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 16 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 16 |
| Service brake: efficiency below requirements |3.7.C.1a| | 16 |
| Horn not working (7.7 (a) (ii)) | 16 |
| Offside Front Headlamp insecure |1.7.3| | 16 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 16 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 16 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 16 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 16 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 16 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 16 |