| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Registration plate lamp issues | 8 |
| Brake pipe excessively corroded | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Exhaust system not adequately supported |7.1.1| | 5 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 5 |
| Headlamp aim out of alignment | 5 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Rear parking brake recording little or no effort | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Rear brake binding | 3 |
| Offside Headlamp insecure (4.1.1 (c)) | 3 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Registration plate issues | 2 |
| Windscreen washer not working | 2 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Service brake grabbing severely |1.2.1 |c|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Brakes imbalanced across an axle | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Upper All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Upper All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced body sill (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced body sill (6.1.1 (c) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced rigger (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill area |7.1.1 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing area |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp insecure headlamp lens .insecure |4.1.1 |c|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength very rear inner sill . |5.3.6 |a| |i|| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front leaf spring mounting |5.3.6 |a| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is severely distorted arch |2.4.A.3| | 1 |
| Rear position lamp|s| not working both |1.1.A.3b| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Position lamp not working nearside rear (4.2.1 (a) (ii)) | 1 |
| Position lamp not working offside rear (4.2.1 (a) (ii)) | 1 |
| Position lamp not working nearside front (4.2.1 (a) (ii)) | 1 |
| Position lamp not working offside front (4.2.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam nearside (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam offside (4.1.1 (a) (ii)) | 1 |
| Headlamp reflector seriously defective nearside (4.1.1 (b) (ii)) | 1 |
| Exhaust system insecure centre section (6.1.2 (a)) | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake load sensing valve linkage defective and function impaired |1.1.17 |a|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Direction indicator not working do not switch off immobiliser fault |4.4.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Main beam tell-tale not working staying on |4.9.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Inner Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Emissions not tested due to engine temperature (8.2.1.2 (d)) | 1 |
| Rear brake application uneven | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Windscreen wiper blade missing |3.4 |b| |ii|| | 1 |
| Offside Front Windscreen wiper blade missing |3.4 |b| |ii|| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |