| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Registration plate lamp issues | 5 |
| Brake pipe excessively corroded | 4 |
| Rear brake binding | 3 |
| Headlamp aim out of alignment | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Emissions not tested |7.0| | 2 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 2 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength turret/inner wing (5.3.6 (a) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Lower Suspension component insecurely attached ball joint nut loose (5.3.3 (a) (i)) | 1 |
| Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Brake cable insecure | 1 |
| Offside Front Drive shaft which forms part of the suspension support bearing excessively worn |2.4.G.4d| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Direction indicator not working side repeater |4.4.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Upper Position lamp not working |4.2.1 |a|| | 1 |
| Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Nearside Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |