Most common failures | No# failures |
---|
Brake pipe excessively corroded | 33 |
Headlamp aim out of alignment | 27 |
Registration plate issues | 24 |
Registration plate lamp issues | 22 |
Windscreen wiper does not clear the windscreen effectively | 18 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 11 |
Brakes imbalanced across an axle | 9 |
Battery insecure |1.9.1| | 6 |
Brake hose excessively deteriorated | 6 |
Front brake disc in such a condition that it is seriously weakened | 6 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
Nearside front brake binding |3.7.B.1| | 4 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Fuel system component leaking |7.2.3| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Front coil spring fractured |2.4.C.1a| | 3 |
Offside Front coil spring broken |2.4.C.1a| | 3 |
Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Nearside Front coil spring broken |2.4.C.1a| | 2 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front coil spring fractured |2.4.C.1a| | 2 |
Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Front Position lamp not working |4.2.1 |a|| | 2 |
Offside Front coil spring incomplete |2.4.C.1a| | 2 |
Windscreen wiper blade insecure | 2 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Rear coil spring broken |2.4.C.1a| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Rear parking brake recording little or no effort | 2 |
Rear brake binding | 2 |
Emissions not tested smoking
|7.4.B.1| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Nearside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` gps |8.3.1e| | 1 |
Offside Brake pipe inadequately supported front to rear |3.6.B.1| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front front brake binding |3.7.B.1| | 1 |
Nearside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Service brake excessively binding both front brakes n/s and o/s grabbing and binding discs in poor condition |1.2.1 |f|| | 1 |
Nearside Steering linkage ball joint modified such that the steering is adversely affected steering ball joint seizing when steering on full lock |2.1.3 |f| |ii|| | 1 |
Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside brake caliper has restricted free movement |3.5.1k| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Front brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chalked (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chalked (5.3.6 (a) (i)) | 1 |
Front Anti-roll bar pin or bush excessively worn Both D bushes (5.3.4 (a) (i)) | 1 |
Front Anti-roll bar linkage ball joint excessively worn Both links (5.3.4 (a) (i)) | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded chassis near anti-roll bar mount |2.4.A.3| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
Nearside Front Fuel pipe insecure |7.2.1| | 1 |
Nearside Front Fuel pipe excessively chafed |7.2.2| | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Rear Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
Anti-roll bar linkage pin or bush likely to become detached NSF and OSF |5.3.4 |a| |ii|| | 1 |
Front Anti-roll bar linkage pin or bush excessively worn both front d bushes (5.3.4 (a) (i)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Front Seat belt anchorage loose (7.1.1 (b)) | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front coil spring cracked |2.4.C.1a| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.1 |c| |ii|| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Outer Fuel pipe leaking |7.2.3| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Brake hose damaged and likely to fail fouling alloy wheel |1.1.12 |a|| | 1 |
Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Front Lower Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting front wheel rear of wheel body mount (6.2.2 (d) (i)) | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis front of rear wheel (6.1.1 (c) (i)) | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Windscreen has damage | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Front Exhaust system insecure bracket broken (6.1.2 (a)) | 1 |
Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Front Fuel system component leaking (6.1.3 (b) (i)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Fuel system component leaking |7.2.3| | 1 |
Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Sill |7.1.1 |a| |i|| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Body |7.1.1 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected Sill as body |5.3.6 |a| |ii|| | 1 |
Nearside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected Sill |5.3.6 |a| |ii|| | 1 |
Nearside Front Steering linkage ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Brake disc significantly and obviously worn scored |1.1.14 |a| |i|| | 1 |
Front Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Seat belt anchorage prescribed area strength or continuity significantly reduced n/s and o/s inner sills corroded and holed front to rear |7.1.1 |a| |i|| | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
Offside Front Seat belt anchorage likely to become detached in the event of a collision inner sill |7.1.1 |a| |ii|| | 1 |
Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing near headlamp above body mount area |6.2.2 |d| |i|| | 1 |
Windscreen washer not working | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Power steering component leaking Suspect leaking from steering rack gaitors |2.1.5 |a|| | 1 |
Battery leaking corrosion on battery |4.13 |b|| | 1 |
Offside Front Hydraulic brake calliper leaking Nipple Leaking (1.1.16 (b) (i)) | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Electrical wiring insecure |1.9.2a| | 1 |
Fuel system component leaking fuel filter |7.2.3| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Fuel system component leaking fuel pump |7.2.3| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded outer sill/wheel arch area |5.2.6| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded centre inner sill |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded centre inner sill |5.2.6| | 1 |
Rear brake application uneven | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Front brake application uneven | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Nearside Rear coil spring broken |2.4.C.1a| | 1 |