| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 16 |
| Registration plate lamp issues | 16 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Headlamp aim out of alignment | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Horn not working |1.6.2a| | 4 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Registration plate issues | 2 |
| Front brake application uneven | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
| Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has damage | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting headlight support |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting headlight support |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill |6.2.2 |d| |i|| | 1 |
| Offside Rear Brake drum contaminated hub seal |1.1.14 |b|| | 1 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired chassis |2.4.A.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Electrical wiring insecure |1.9.2a| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Power steering disconnected where it is standard fitment |2.3.3a| | 1 |
| Nearside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Wheel stud|s| loose |4.2.A.1e| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Outer Position lamp not working side light not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Outer Position lamp not working side light not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outer Position lamp not working side light not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Suspension component attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Suspension component attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Body insecure (6.2.2 (a) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wheelarch (7.1.1 (a) (i)) | 1 |