MOT History from tests of petrol SUZUKI CARRYs year 1999

Review the list of common SUZUKI CARRY failures below or to perform a specific mot history check on your SUZUKI then use our popular KnowYourCar service

mot history

Pass percent:58.90%

(The average a petrol SUZUKI CARRY year 1999 passes without issue)

Based on:7,112 MOT Tests

Most common failures	No# failures
Windscreen wiper does not clear the windscreen effectively	529
Headlamp aim out of alignment	351
Brake pipe excessively corroded	330
Registration plate lamp issues	290
Exhaust emissions carbon monoxide content after 2nd fast idle excessive \|7.3.D.3\|	254
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits \|7.3.D.3\|	210
Offside Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	133
Registration plate issues	128
Nearside Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	126
Rear Exhaust system not adequately supported \|7.1.1\|	126
Exhaust emissions carbon monoxide content at idle excessive \|7.3.D.4\|	124
Offside Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	116
Exhaust has a major leak of exhaust gases \|7.1.2\|	114
Offside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	92
Nearside Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	87
Rear parking brake recording little or no effort	83
Centre Exhaust has a major leak of exhaust gases \|7.1.2\|	82
Brakes imbalanced across an axle	78
Rear brake binding	76
Exhaust emissions hydrocarbon content after 2nd fast idle excessive \|7.3.D.3\|	70
Offside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	69
Nearside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	68
Nearside Stop lamp not working \|1.2.1b\|	65
Offside Stop lamp not working \|1.2.1b\|	64
Horn not working \|1.6.2a\|	63
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	63
Parking brake: efficiency below requirements \|3.7.B.7\|	60
Nearside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	58
Nearside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	55
Offside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	55
Parking brake lever has no reserve travel \|3.1.6b\|	53
Exhaust system not adequately supported \|7.1.1\|	52
Emissions not tested \|7.0\|	50
Offside Rear fog lamp not working \|1.3.2b\|	50
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement \|7.2.4b\|	47
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	46
Nearside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	46
Offside Front Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	45
Windscreen has damage	43
Offside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	43
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b))	37
Front brake disc in such a condition that it is seriously weakened	36
Exhaust has part of the system excessively deteriorated \|7.1.1a\|	34
Nearside Front Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	33
Rear Exhaust has a major leak of exhaust gases \|7.1.2\|	33
Offside Headlamp not working on dipped beam \|1.7.5a\|	31
Rear Exhaust mounting missing \|7.1.1b\|	30
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))	29
Offside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	29
Rear Exhaust has part of the system excessively deteriorated \|7.1.1a\|	29
Offside Front brake disc excessively pitted \|3.5.1h\|	29
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	28
Offside front brake binding \|3.7.B.1\|	28
Steering system has excessive free play detected at the steering wheel \|steering rack fitted\| \|2.2.A.1b\|	27
Offside Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	25
Nearside Front brake disc excessively pitted \|3.5.1h\|	25
Nearside Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	24
Nearside Front Macpherson strut has excessive movement at the upper attachment \|2.5.A.1c\|	22
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	22
Nearside Rear Stop lamp not working \|1.2.1b\|	22
Nearside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	21
Rear fog lamp not working \|1.3.2b\|	20
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	20
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	20
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	20
Brake hose excessively deteriorated	20
Nearside front brake binding \|3.7.B.1\|	20
Offside Rear Stop lamp not working \|1.2.1b\|	20
Lower Steering column universal joint has excessive play \|2.1.5\|	19
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	19
Offside Front Macpherson strut has excessive movement at the upper attachment \|2.5.A.1c\|	18
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	18
Offside Windscreen wiper blade deteriorated \|8.2.2\|	18
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	17
Nearside Windscreen wiper blade deteriorated \|8.2.2\|	17
Fuel cap/sealing device does not fasten securely by positive means \|7.2.4b\|	16
Rear brake application uneven	16
Nearside Headlamp not working on dipped beam \|1.7.5a\|	15
Centre Exhaust has part of the system excessively deteriorated \|7.1.1a\|	15
Nearside Front Subframe mounting prescribed area is excessively corroded \|2.4.A.3\|	15
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt \|5.2.2a\|	15
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	15
Offside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	14
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a))	14
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	14
Offside Front Subframe mounting prescribed area is excessively corroded \|2.4.A.3\|	14
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits \|8.2.1.2 \|b\|\|	14
Offside Front Lower Ball joint has excessive play \|2.2.B.1f\|	14
Bonnet cannot be secured in the closed position \|8.4.1\|	13
Nearside Headlamp insecure \|1.7.3\|	13
Steering column universal joint has excessive play \|2.1.5\|	13
Fuel cap/sealing device missing \|7.2.4a\|	13
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	13
Front brake application uneven	12
Offside Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	12
Front brake disc excessively pitted \|3.5.1h\|	12
Offside Rear position lamp\|s\| incorrect colour \|1.1.A.3e\|	12
Nearside Rear position lamp\|s\| incorrect colour \|1.1.A.3e\|	12
Nearside Front Lower Ball joint has excessive play \|2.2.B.1f\|	12
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))	11
Nearside Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	11
Offside Front Ball joint has excessive play \|2.2.B.1f\|	11
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` \|8.3.1e\|	11
Offside Headlamp insecure \|1.7.3\|	11
Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	11
Offside Headlamp not working on main beam \|1.7.5a\|	11
Offside Inner Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	11
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	11
Nearside Side repeater not working \|1.4.A.2c\|	10
Offside Rear Rear fog lamp not working \|1.3.2b\|	10
Service brake: efficiency below requirements \|3.7.B.7\|	10
Nearside Rear Exhaust system not adequately supported \|7.1.1\|	10
Exhaust tailpipe not capable of allowing the emission probe to be inserted \|7.3.D.1\|	10
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	10
Nearside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	10
Windscreen wiper blade insecure	10
Offside rear brake recording little or no effort \|3.7.B.5a\|	10
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	10
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	9
Nearside rear brake recording little or no effort \|3.7.B.5a\|	9
Rear Mechanical brake component has restricted free movement	9
Offside Front front brake binding \|3.7.B.1\|	9
Nearside Front Ball joint has excessive play \|2.2.B.1f\|	9
Nearside Rear wheel bearing rough when rotated \|2.6.1\|	9
Offside Front Seat belt locking mechanism does not secure or release \|5.2.5a\|	9
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	9
Offside Suspension arm has excessive play in a ball joint \|2.4.G.2\|	9
Rear Stop lamp not working \|1.2.1b\|	9
Exhaust Lambda reading after 2nd fast idle outside specified limits \|8.2.1.2 \|c\|\|	9
Supplementary Restraint System warning lamp indicates a fault \|5.4.2\|	9
Rear Rear fog lamp not working \|1.3.2b\|	9
Offside Inner Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	9
Offside Front Wheel nut\|s\| missing \|4.2.A.1e\|	9
Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	9
Nearside Front front brake binding \|3.7.B.1\|	9

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of petrol SUZUKI CARRYs year 1999

Find us on Facebook