| Most common failures | No# failures |
|---|
| Rear brake binding | 13 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Brakes imbalanced across an axle | 7 |
| Registration plate lamp issues | 5 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Horn not working |1.6.2a| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Rear brake application uneven | 3 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Headlamp aim out of alignment | 2 |
| Battery insecure |1.9.1| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Registration plate issues | 2 |
| Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Centre Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Outer Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Brake clevis joint insecure |3.5.1d| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Brake rod locking device missing |3.5.1l| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Hydraulic brake cylinder operating mechanism has excessive travel (1.1.16 (e) (i)) | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Offside Rear Brake lining|s| contaminated axle leak |1.1.13 |b|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Rear brake excessively fluctuating | 1 |
| Direction indicator not working n/s/f |1.4.A.2c| | 1 |
| Direction indicator not working n/s/r |1.4.A.2c| | 1 |
| Indicator tell tale inoperative nearside tel tale |1.4.A.2a| | 1 |
| Exhaust system not adequately supported rear exh mount broken |7.1.1| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Brake hose damaged | 1 |
| Offside Front suspension retaining device missing |2.5.A.4| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded Outer sill/door step |5.2.6| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded Chassis |2.4.A.3| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded Inner wing and bulkhead |3.6.C.3| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| Steering idler |2.2.A.1a| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel hose insecure to fuel filter |7.2.1| | 1 |
| Electrical wiring inadequately supported engine bay |1.9.2a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front brake caliper securing device loose |3.5.1j| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush (2.4.G.2) | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake rod has restricted free movement |3.5.1k| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Nearside Front Lower Axle swivel joint insecure in a stub axle |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint insecure in a stub axle |2.5.A.3b| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Shock absorbers likely to become detached |5.3.2 |a| |ii|| | 1 |
| Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced n/s o/s rear of rear springs |6.1.1 |c| |i|| | 1 |
| Rear Braking system leaking brake pipe |3.6.A.1| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength at front of leaf (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength at front of leaf (5.3.6 (a) (i)) | 1 |
| Central Seat belt anchorage prescribed area strength or continuity significantly reduced near side cross member (7.1.1 (a) (i)) | 1 |
| Central Seat belt anchorage prescribed area strength or continuity significantly reduced off side cross member (7.1.1 (a) (i)) | 1 |
| Windscreen wiper blade insecure | 1 |
| Stop lamp not working all |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded front spring hanger area |2.4.A.3| | 1 |
| Nearside Lower Front suspension has excessive movement at a wishbone pin or bush trunion |2.5.A.1c| | 1 |
| Offside Lower Front suspension has excessive movement at a wishbone pin or bush trunion |2.5.A.1c| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Rear Brake clevis joint locking device insecure |3.5.1l| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded chassis |3.1.9| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded under wing /chassis |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill /arch |2.4.A.3| | 1 |
| Headlamp switch faulty dipswitch extingishes headlights |1.7.1| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Vehicle structure has excessive corrosion which adversely affects braking or steering sill |6.1.A.1| | 1 |