| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 58 |
| Headlamp aim out of alignment | 37 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 34 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 26 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 14 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 8 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 8 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 8 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 7 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 6 |
| Windscreen washer not working | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 5 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Registration plate lamp issues | 4 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 4 |
| Brake pipe excessively corroded | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 3 |
| Front Bonnet primary retaining device ineffective (3.1 (c)) | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Registration plate issues | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Central Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 2 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn o/s/f suspension arm rear bush worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn n/s/f suspension arm rear bush worn (5.3.4 (a) (i)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both D bushes (5.3.4 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Brake performance unable to be tested Front pads are below 1.5mm (1.2.1 (g)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Outer Stop lamp(s) not working Nsr brake light not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D-BUSH (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D-BUSH (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush of wishbone (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush of wishbone (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Steering arm deformed to the extent that steering is affected Track rod Bent. (2.1.3 (c) (ii)) | 1 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Front Suspension arm pin or bush excessively worn both bottom arm rear bushes pulled through (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Front Boot lid cannot be secured in the closed position bonnet (6.2.1 (e)) | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Rear Bumper insecure |6.1.4 |a| |i|| | 1 |
| Nearside Front Body panel insecure Wing arch |6.2.1 |a| |i|| | 1 |
| Nearside Front Body component damaged and likely to cause injury Door mirror |6.2.1 |a| |i|| | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Brake performance unable to be tested Not tested due to rear offside wheel bearing likely to collapse. (1.2.1 (g)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn Bottom ball joint. (5.3.4 (a) (i)) | 1 |
| All direction indicators not working all indicators/ hazards flashing at all times with ignition on + running, switching indicator stalk has no effect (4.4.1 (a) (ii)) | 1 |
| Front Electronic stability control warning lamp indicates a fault instrument cluster (7.12 (e)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Bumper damaged and likely to cause injury when grazed or contacted front grille major damage and alot of sharp edges (6.1.4 (a) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Rear Seat belt buckle missing centre (7.1.2 (d)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Brake disc contaminated all 4 (1.1.14 (b)) | 1 |
| Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Bonnet primary retaining device excessively deteriorated bonnet cannot be opened or closed (3.1 (c)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Brake disc significantly and obviously worn both front excessively corroded (1.1.14 (a) (i)) | 1 |
| Brake disc significantly and obviously worn both front and rear (1.1.14 (a) (i)) | 1 |
| Front Service brake grabbing severely |1.2.1 |c|| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Anti-lock braking system wiring excessively damaged Front both sides (1.6 (d)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Nearside Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Central Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear All position lamps adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Electronic power steering warning lamp indicates a system malfunction (2.6 (a)) | 1 |