| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Headlamp aim out of alignment | 11 |
| Brake pipe excessively corroded | 8 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
| Offside Steering rack gaiter split |2.2.D.2d| | 7 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Registration plate lamp issues | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Brakes imbalanced across an axle | 4 |
| Registration plate issues | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill/inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill/inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch area |6.1.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen has damage | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Steering locking device insecure |2.2.C.1g| | 1 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension damaged |2.4.G.4a| | 1 |
| Front Brake pipe leaking |3.6.A.1| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Outer Steering rack gaiter split |2.2.D.2d| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |